Frost Fighter IDH1000 Manuel utilisateur

IDH1000 FEATURES AND OPERATION MANUAL

VER. 1.3.2 SEPT. 2019 2019

Table of Contents

- Fuel Fill Location & Filling Precautions

- Door latches, Compartments and Hitch/Tongue Details

- External Power Connections

- Heater Access Doors and Slide Out System

- Basic Features of Heaters (See heater manual for full operating & servicing information)

Engine/Generator Layout and Identification (See engine manual for engine type specific detailed information)

Rear Compartment Controls & Functions

Fuel Level Sending Unit

Compartment Lighting Control Timers - Function & Adjustment

-Basic Starting Instructions for the Kubota or Isuzu Diesel Engine

-Isuzu Engine Basic Spare Parts List

-Kubota Engine Basic Spare Parts List

-Kubota Engine Oil Requirements

-Location of Rating Plate Information and Serial Number Identification - List of Important Warnings & Precautions

-Optional LED Status Beacon

-120VAC & 12VDC Standard Circuit Wiring Diagram

-Recommended Maintenance / Service Intervals

-Operating Tips and Specifics

-Overall Exterior Dimensions

Page 2

Page 3-4

Page 5

Page 6 - 8

Page 9

Page 10

Page 11 - 12

Page 13

Page 14 - 15

Page 16

Page 17

Page 18

Page 19

Page 20

Page 21

Page 22 - 24

Page 25

Page 26

APPENDIX A

Fuel Fill Point

CAUTION:

Filling the fuel tank too quickly or overfilling the tank can increase the risk of spills, backsplash or fuel discharging from the tank vent or fill point due to fuel expansion, etc.

Page 2

EXTERIOR FUEL FILL AREA LIGHT

Activated with compartment light button located on main control panel

FUEL LEVEL FILL WARNING INDICATOR

This indicator can assist with eliminating the risk of overfilling or splash-back.

-Green LED begins flashing when fuel level reaches 75% of full tank capacity

-Green LED Illuminates steady when fuel level reaches 85% to 90% of full tank capacity

(Engine must be stopped and key switch must be ON to activate this feature)

The fuel tank is filled on the side of unit near the rear.

Maximum fuel tank capacity is 190 US gal (718 Litres)

Caution: Do not fill tank above 95% of maximum capacity to allow for fuel expansion.

Refer to rating plate in rear compartment for specific details.

Approximate maximum run time for IDF1000 with full tank is approx. 30 hours.

Positive Lock Access Door Latches

Door Latches in Closed Position Press Bottom of Latches to Open

Page 3

Left front storage compartment access door.

Trailer tongue area illustrating various components

Always ensure tow vehicle has sufficient tow ratings and reduce speed when towing

Break-away switch

battery.

Check battery

condition

annually

Tongue jack

7 Pin trailer

connector to vehicle

for exterior lights and

electric brakes

Break-away switch

Safety chains

Height adjustable hitch

Pintle or 2-5/16” ball

available

Page 4

External Power Connections

•

120VAC 15A "shore power" inlet to supply engine block heater

and battery charger/maintainer.

•

120VAC 15A GFCI protected auxiliary power

outlet

Page 5

Swing Open Side Access Doors

Access to Heater Discharges

Heater discharge doors have safety interlock switches

and each door must be open in order for the respective

heater to operate.

Access to Heater Controls

Heater inlet doors provide access to the heater

controls and should normally remain open

during operation.

Catches are provided to

secure doors in the open

position

Page 6

Heaters are mounted onto poly lined slides rails permitting slide out access for service or complete removal from

enclosure.

IDH500QR heaters can slide out toward the burner end only and IDF500HS heaters can slide out from both the burner

end or the air discharge end.

Illustration of "Lock Bolts" which secure slide rails in locked position. These must be removed in order to slide heaters)into service position

Page 7

SLIDE LOCK BOLT

Illustration of a heater pulled into access positions.

Heater travel is limited by "slide limit stop bolts". The heaters can be completely

removed from the enclosure by unfastening the slide limit safety stop bolt.

Note: IDH models slide-out from the burner side of the trailer only & require lifting of the clearance cover.

Page 8

IDH500QR HEATER SHOWN

SLIDE STOP BOLT

REMOVE 2

“CLEARANCE COVER”

BOLTS

SWING “CLEARANCE COVER”

OPEN

OPENING CLEARANCE COVER TO

SLIDE OUT HEATERS

IDF500HS and IDH500QR Heaters

PRESSURE GAUGE

KEEP VALVE CLOSED DURING NORMAL OPERATION & OPEN TO

ONLY TO CHECK PRESSURE.

FUEL FILTER

FUEL

SOLENOID

AIR

ADJUSTMENTS

IGNITION

TRANSFORMER

GENISYS CONTROL

RED “LOCKOUT” INDICATOR

AND RESET BUTTON

FUEL SOLENOID VALVE

“ENERGIZED” INDICATOR

POWER SUPPLY

INDICATOR

BURNER OPERATION SELECTOR

SWITCH.

OFF / MANUAL / THERMOSTAT

BURNER CIRCUIT

BREAKER

GENISYSY 7505

CONTROL

REMOTE

THERMOSTAT

CONNECTION

Burner Controls and Functions

See heater manual for complete operation and maintenance information

Page 9

Autres manuels pour IDH1000

Autres manuels Frost Fighter Chauffage

Frost Fighter

Frost Fighter IDHQR Series Fiche technique

Frost Fighter

Frost Fighter IDH500QR LP/NG Fiche technique

Frost Fighter

Frost Fighter DF 400 Manuel utilisateur

Frost Fighter

Frost Fighter IDH200QR OIL Mode d’emploi

Frost Fighter

Frost Fighter IDH1000 Manuel utilisateur

Frost Fighter

Frost Fighter IDH200QR OIL Fiche technique

Frost Fighter

Frost Fighter IHS 1500 Manuel

Frost Fighter

Frost Fighter IDF350-II Instructions générales

Frost Fighter

Frost Fighter IHS700P LP Fiche technique

Frost Fighter

Frost Fighter IDH400QR LP/NG Fiche technique

Frost Fighter

Frost Fighter IDF1000 Manuel utilisateur

Frost Fighter

Frost Fighter IHS700P LP Fiche technique

Frost Fighter

Frost Fighter IDF500HS Fiche technique

Manuels Chauffage populaires d'autres marques

oventrop

oventrop Regucor Series Manuel utilisateur

Blaze King

Blaze King CLARITY CL2118.IPI.1 Manuel utilisateur

ELMEKO

ELMEKO ML 150 Manuel utilisateur

BN Thermic

BN Thermic 830T Manuel utilisateur

KING

KING K Series Mode d’emploi

Empire Comfort Systems

Empire Comfort Systems RH-50-5 Guide de démarrage rapide

Well Straler

Well Straler RC-16B Manuel utilisateur

EUROM

EUROM 333299 Manuel utilisateur

Heylo

Heylo K 170 Manuel utilisateur

Eterna

Eterna TR70W Manuel utilisateur

Clarke

Clarke GRH15 Mode d’emploi

IRSAP

IRSAP The Radiator Company Ovali Manuel utilisateur

Empire Heating Systems

Empire Heating Systems WCC65 Manuel utilisateur

Wetekom

Wetekom 92 86 43 Manuel utilisateur

Desa

Desa SPC170-F Manuel utilisateur

Watlow

Watlow Watrod Electric Tubular Heaters Manuel utilisateur

Haverland

Haverland ECO-DRY GPS Series Manuel de la liste des pièces

Stelpro

Stelpro ASILVC2060 Series Manuel utilisateur