Flightcell DZMx Plus Manuel utilisateur
MAN_DZ7_001 Rev 1.1 Flightcell® DZMx Plus Installation Manual
Effective Date: 28 Jun 2021
DZMx Plus Installation Manual
Product Rev 1.3
MAN_DZ7_001 Rev 1.1 Flightcell® DZMx Plus Installation Manual Page 2 of 61
Effective Date: 28 Jun 2021
Section 1: Manual Revisions and Approvals
Revision
Effective Date
Approved By
Reasons for Change
1.1
28 Jun 2021
James Mace
Richard Benfield
New issue
Except as expressly provided below, no part of this document may be reproduced, copied,
transmitted, disseminated, downloaded, or stored in any storage medium, for any purpose
other than that which Flightcell International has provided this document for. Any electronic
or printed copy of this document or any revision must contain the complete text of this
copyright notice. Any unauthorised commercial distribution of this document or any revision
hereto is strictly prohibited. Information in this document is subject to change. Document
users are responsible for ensuring printed copies are valid prior to use.
© Copyright 2021 Flightcell International Ltd –All Rights Reserved
MAN_DZ7_001 Rev 1.1 Flightcell® DZMx Plus Installation Manual Page 3 of 61
Effective Date: 28 Jun 2021
TABLE OF CONTENTS
Section 1: Revisions and Approvals_____________________________________ 2
Section 2: Introduction _______________________________________________ 5
Section 3: DZMx Equipment ___________________________________________ 6
Connectors ____________________________________________________________________ 6
Section 4: DZMx Plus Specifications ____________________________________ 7
Variants and Part Numbers _______________________________________________________ 7
Dimensions____________________________________________________________________ 7
Electrical ______________________________________________________________________ 8
Environmental/EMI Qualifications _________________________________________________ 9
Section 5: Installation _______________________________________________ 10
Mountingthe DZMx ____________________________________________________________ 10
DZMx Plus Wiring Guide ________________________________________________________ 11
Installing a DZMx Plus Control Head _______________________________________________ 17
DZMx PlusAntennas____________________________________________________________ 17
Section 6: Configuration _____________________________________________ 19
Configuring the DZMx Plus_______________________________________________________ 19
Audio Installation and Configuration ______________________________________________ 21
Modem Configuration __________________________________________________________ 25
Backlighting __________________________________________________________________ 29
DZMx Plus WiFi________________________________________________________________ 32
DZMx Plus Bluetooth™__________________________________________________________ 33
DZMx Tracking ________________________________________________________________ 35
DZMx Plus Inputs and Outputs ___________________________________________________ 43
ConfiguringDZMxPlusData _______________________________________________________ 46
DZMx Plus Data Logging_________________________________________________________ 49
DZMx Plus Email Outbox ________________________________________________________ 51
Recording and Transmitting Maintenance Data______________________________________ 51
Section 7: DZMx Plus Applications ____________________________________ 53
DZMx Plus Applications and Licences ______________________________________________ 53
DZMx Plus Applications _________________________________________________________ 53
Section 8: Maintenance, Diagnostics and Support ________________________ 54
Firmware Upgrades ____________________________________________________________ 54
MAN_DZ7_001 Rev 1.1 Flightcell® DZMx Plus Installation Manual Page 4 of 61
Effective Date: 28 Jun 2021
Diagnostics ___________________________________________________________________ 55
Flightcell Remote Assistance _____________________________________________________ 56
Section 9: Documentation and Information ______________________________ 58
Contact Details ________________________________________________________________ 58
Warranty_____________________________________________________________________ 58
Appendix 1: Connector Kits & Associated Parts ___________________________ 60
MAN_DZ7_001 Rev 1.1 Flightcell® DZMx Plus Installation Manual Page 5 of 61
Effective Date: 28 Jun 2021
Section 2: Introduction
This manual provides information on the installation and configuration of the DZP_07-
xxx-xxxx Flightcell DZMx Plus.
MAN_DZ7_001 Rev 1.1 Flightcell® DZMx Plus Installation Manual Page 6 of 61
Effective Date: 28 Jun 2021
Section 3: DZMx Equipment
The DZMx Plus should be inspected when unpacked to check for any visible damage or
missing components.
Connectors
Connector kits are supplied with the DZMx Plus Transceiver DZP_07-xxx-xxxx and the
DZMx Plus Control Head DZP_05-002 including Bluetooth and WiFi antennas. The content
of the connector kits depends on the version of the DZMx Plus. Optional extras based on the
unit dash number and customer requirements will be at additional cost.
Details of the connector kit contents are provided in Appendix 1.
MAN_DZ7_001 Rev 1.1 Flightcell® DZMx Plus Installation Manual Page 7 of 61
Effective Date: 28 Jun 2021
Section 4: DZMx Plus Specifications
Variants and Part Numbers
The DZMx Plus can be built with a range of hardware options.
The DZMx part number is DZP_07. The 3 - 7 digit dash number immediately following DZP_07-
xxx-xxxx designates the variant of the DZMx Plus.
The available variants may change from time to time. The options available to build up the
different variants are:
»Installed modems (see "Modem Configuration" on page 24 for a list of supported mode
ms)
»Additional circuit cards
»Second ethernet
»ARINC 429
»Input expansion card
Dimensions
Dimension
DZMx Plus
DZMx Plus Control Head
DZUS mount
Faceplate Width
N/A
146mm
Extrusion Width
N/A
126mm
Faceplate Height
N/A
57mm
Extrusion Height
N/A
54mm
Depth
N/A
23mm
Weight
1.6kg (depending on configuration)
200 grams
Length
240mm
N/A
Width
58mm
146mm
Height
188mm
57mm
MAN_DZ7_001 Rev 1.1 Flightcell® DZMx Plus Installation Manual Page 8 of 61
Effective Date: 28 Jun 2021
Electrical
DZMx PLUS MAIN TRANSCEIVER MODULE
Part/Item
Parameter
Value
Power
Input Voltage
12-32VDC
Power Supply Current
Up to 1.5A @28VDC
ICS to DZM Audio
Input Levels
20mVrms to 1.15Vrms, adjustable
775mVrms to 1.15RMS nominal
Input Impedance
600Ω
Microphone bias voltage
12V via 2.2kΩ
DZM to ICS Audio
Output levels
Up to 5Vrms, adjustable
775mVRMS nominal
Output Impedance
150Ω
GPS
Antenna bias voltage
5V
Antenna current
Up to 100mA
Sensitivity
-162dBm (with Flightcell Antenna)
Time to first fix
26s
WiFi
Tx power (dBm)
17.3
Antenna gain (dBi)
2.6
Total power (dBm)
19.9
Total power (mW)
97.7
Bluetooth
Tx power (dBm)
10
Antenna gain (dBi)
2.6
Total power (dBm)
12.6
Total power (mW)
18.2
RF Frequency Range
1616 MHz to 1625.5 MHz
Satellite
Iridium
Tx power (max)
7W
Antenna gain (dBi)
3
RF RX Sensitivity
-118 dBm
Max Cable Loss
3 dB
Antenna impedance
50 Ω
USER INTERFACE
Power switch
Momentary action switch PWR on/off with backlight
LEDs
Transceiver Status Indicator x3
MAN_DZ7_001 Rev 1.1 Flightcell® DZMx Plus Installation Manual Page 9 of 61
Effective Date: 28 Jun 2021
CONTROL HEAD SPECIFICATION
Part/Item
Parameter
Value
Power
Input Voltage
12-32VDC
Supply Current
Up to 1A @ 28VDC
Data connection
RS485 full duplex
Serial data interface between Control
Head and DZMx Plus
Backlighting
Input Control
User-configurable fixed level or
controlled from an external lighting
dimmer. 0-28VDC or user-
configurable response
Colour
Green 540nm. Designed for NVIS B
compliance
USER INTERFACE
Keypad
16 Button Keypad
LCD Display
LCD backlit monochrome
Environmental/EMI Qualifications
The DZMx Plus is designed against RTCA DO-160G. Test results are pending.
Details of the DO-160G compliance will be provided in the DZMx Plus Declaration of Design
and Performance (DDP) document which is pending.
DO-160G test reports shall also be available on request from tech@flightcell.com.
MAN_DZ7_001 Rev 1.1 Flightcell® DZMx Plus Installation Manual Page 10 of 61
Effective Date: 28 Jun 2021
Section 5: Installation
DZMx Plus Mechanical Assembly ARINC 600 Tray
DZMx Plus Mechanical Assembly Standard Tray
Mounting the DZMx
The DZMx Plus Control Head should be mounted where the flight crew or radio operator
have a clear view of the display and can easily use the keypad.
If the DZMx Plus Control Head is installed in the pedestal, for ease of use, it is preferable to
install it as near to the front of the pedestal as possible.
The DZMx Plus LCD is designed for optimum readability when viewed at angles between 60°
above the display to 20° below. Avoid mounting the unit where the display will be viewed at
an oblique angle, as it may not be clearly readable. It is preferable to mount the DZMx Plus
to minimise sunlight shining on the display.
Autres manuels pour DZMx Plus
1
Table des matières
Autres manuels Flightcell GPS
