EVERLAST CLIMBING KERSPLASH Manuel utilisateur

KERSPLASH®POOL CLIMBING WALL INSTALLATION INSTRUCTIONS

TOLL FREE 1-800-476-7366 |VOICE 651-665-9131 |FAX 651-665-9130 |[email protected]

WWW.EVERLASTCLIMBING.COM |1335 MENDOTA HEIGHTS ROAD, MENDOTA HEIGHTS, MN 55120

1-800-476-7366 | [email protected] |WWW.EVERLASTCLIMBING.COM

KERSPLASH®POOL CLIMBING WALL INSTALLATION INSTRUCTIONS

Congratulations! You have purchased a Kersplash Pool Climbing

Wall from Everlast Climbing. Providing the unit is installed

correctly and properly maintained, it will furnish you with many

years of trouble free use. It is important to read this entire

manual prior to beginning assembly or operation.

Shipping Information:

Each wall module will arrive partially assembled in a crate. Before accepting

the unit from the carrier, inspect for visible damage and match the contents

with those listed below. Everlast Climbing is not responsible for lost or

damaged freight.

The crate will contain all structural components, hardware, and panels.

The following is a list of the components included with your shipment from

Everlast Climbing. Use Components and Hardware Figure A, page 3, as a

reference to identify each item listed.

16’ Climbing Wall: Part Number 70537 Crystal Clear®Panel, 42639 Color

1304L Stainless Steel

Climbing Frame 4 4’ x 4’ Climbing Panels

1 2’ x 4’ Safety Panel 1 Hardware Package

6 Anchoring Brackets 3 Kersplash Climbing Wall Rules Signs

36 Groperz™ Hand Holds

12’ Climbing Wall: Part Number 70536 Crystal Clear Panel, 42638 Color

1 304L Stainless Steel

Climbing Frame

3 4’ x 4’ Climbing Panels

1 2’ x 4’ Safety Panel 1 Hardware Package

4 Anchoring Brackets 3 Kersplash Climbing Wall Rules Signs

27 Groperz Hand Holds

8’ Climbing Wall: Part Number 42627 Crystal Clear Panel, 42648 Color

1 304L Stainless Steel

Climbing Frame

2 4’ x 4’ Climbing Panels

1 2’ x 4’ Safety Panel 1 Hardware Package

4 Anchoring Brackets 3 Kersplash Climbing Wall Rules Signs

18 Groperz Hand Holds

1-800-476-7366 | [email protected] |WWW.EVERLASTCLIMBING.COM

KERSPLASH®POOL CLIMBING WALL INSTALLATION INSTRUCTIONS

Components & Hardware Figure A

2’ X 4’ SAFETY PANEL

4’ X 4’ CLIMBING PANEL

CLIMBING FRAME

ANCHORING BRACKET

1-800-476-7366 | [email protected] |WWW.EVERLASTCLIMBING.COM

KERSPLASH®POOL CLIMBING WALL INSTALLATION INSTRUCTIONS

4’

CLEAR DECK SPACE FIGURE B

Installation Overview

Please make sure to read all instructions before attempting to assemble

or install the wall. Due to the wide variety of pool deck conﬁgurations, it is

recommended that you contact Everlast Climbing for a drawing packet that will

conﬁgure the mounting holes, spacers, and setback for your deck application.

Tools & Equipment Required:

• Hammer Drill

• 5/8” Hammer Drill Bit

• Compressed Air

• Steel Brush

• 7/32” Allen Wrench (included)

• 9/16” socket and ratchet

• Vise Grip

• Hammer

CLEAR DECK SPACE

To be compliant with most state and local guidelines there must be at least

4’ of clear deck space from the back of the frame on the deck to any

obstruction. Please verify your local and state codes prior to installation.

SEE FIGURE B

POOL DEPTH

Pool depth requirements vary by state. Check your state and local codes

to ensure your conﬁguration complies. Everlast Climbing recommends the

following depths for its different panel conﬁgurations: SEE FIGURE C

WALL HEIGHT RECOMMENDED WATER DEPTH

8 FEET 5 ft

12 FEET 6 ft

16 FEET 9 ft

CLIMBING WALL ASSEMBLY

Assembly will take place in four steps.

1) Attach holds to panels

2) Attach panels to frame

3) Tip up ﬁrst frame and install two anchors. Tip up second frame, bolt

frames together and install two additional anchors on second frame.

Repeat until all frames are standing.

4) Anchor frames to deck with the remaining Hilti Kwik Bolts

5’ DEPTH

6’ DEPTH

9’ DEPTH

POOL DEPTHS FIGURE C

1-800-476-7366 | [email protected] |WWW.EVERLASTCLIMBING.COM

KERSPLASH®POOL CLIMBING WALL INSTALLATION INSTRUCTIONS

Installation Instructions

Prior to assembly, be sure to gather all of your tools and prepare all

materials. If a Crystal Clear wall is chosen, the protective wrapping will

need to be removed from the panels prior to assembly, and care taken

not to scratch the panels during the installation process.

ATTACHING THE HAND HOLDS

1. Place the Hand Hold over the desired set of holes in the wall panel.

2. Insert 2” button head bolt, 3/8” lock washer, and 3/8” washer through

the Hand Hold and through the 1/2” clear panel. Attach the 3/8” rubber

sleeve washer over the bolt threads and thread on the 3/8” lock nut.

3. Using an Allen Wrench (included) and a 9/16” box wrench or socket

wrench, hand tighten.

4. Repeat steps 2 and 3 for the second bolt.

a b c g

a. Allen Wrench

b. 2” Button Head Bolt

c. 3/8” Lock Washer

d. 3/8” Washer

e. Hand Hold

f. Panel

g. Seal Washer

h. 3/8” Lock Nut

1-800-476-7366 | [email protected] |WWW.EVERLASTCLIMBING.COM

KERSPLASH®POOL CLIMBING WALL INSTALLATION INSTRUCTIONS

ATTACHING THE CLIMBING PANELS TO THE FRAME

NOTE: If your environment is humid, we recommend applying an extra coat of Spectra Shield to

the frame. To order, contact Spectrum Aquatics (Part Number 202050-00), at 800.791.8056.

Lay the stainless steel frame on its back with the spine towards the ground.

Place the panels on top of the frame and drop in button head screws to

hold the panels in place, but do not tighten. For ease of installation and to

accommodate manufacturing and temperature variances, each climbing

panel has 6 mounting slots that allow for adjustment when attaching the

panels to the frame. For the bottom panel, center the fasteners in each of

these slots.

Attach the climbing panel to the climbing frame as shown

below using the following hardware:

6 - 3/8” x 1 ¼” Button Head Socket Screw

6 - 3/8” Flat Washers

6 - 3/8” Nylock Nuts

Afﬁx the 2’ x 4’ safety panel to the top of the climbing frame using:

4 - 3/8” x 1 ¼” Button Head Socket Screws

4 - 3/8” Flat Washers

4 - 3/8” Nylock Nuts

1-800-476-7366 | [email protected] |WWW.EVERLASTCLIMBING.COM

KERSPLASH®POOL CLIMBING WALL INSTALLATION INSTRUCTIONS

POSITIONING, TEMPORARY ANCHORING,

AND CONNECTING THE FRAMES:

•Themainframeoftheclimbingwallshouldbesetsothatthereisnoless

than 1” and no more than 4” of clearance between the climbing wall and

the existing pool wall (verify local and state codes). SEE FIGURE D

•Positiontherstframeuprightonthepooldeck.Settheframewitha

mechanical anchor in the front middle bracket and rear middle bracket.

SEE FIGURE E

•Positionthesecondframenexttotherst.Therearetwoplaceswhere

the frames must be fastened together, one about 2’ down from the top

and the next about 1’6” up from the pool deck. Fasten the two frames

together using fasteners. SEE FIGURE F

2 - 3/8” x 4 1/2” Hex Screws

4 - 3/8” Flat washers

2 - 3/8” Nylock Nuts

•Thensetthesecondframewithananchorinthefrontmiddlebracket

and back middle bracket. Continue in this manner until all frames are set.

SEE FIGURE E

FASTEN FRAMES TOGETHER FIGURE F

1” to 4” FROM EDGE

OF CLIMBING WALL

FRAME TO DECK

DECK

POOL

FRAME TO DECK CLEARANCE FIGURE D

POOL WALL FRAME

POSITION UPRIGHT AND SET BACK MIDDLE BRACKET FIGURE E

REAR ANCHOR POINTS

MIDDLE BRACKETS

ANCHORS

OUTSIDE BRACKETS

ANCHORS

OUTSIDE BRACKETS

ANCHORS

FRONT ANCHOR POINTS

REQUIRED BRACKET POSITIONS:

16’ WALL - 6 REQUIRED BRACKETS: 3 FRONT, 3 REAR

12’ WALL - 4 REQUIRED BRACKETS: 2 FRONT, 2 REAR

8’ WALL - 4 REQUIRED BRACKETS: 2 FRONT, 2 REAR

1-800-476-7366 | [email protected] |WWW.EVERLASTCLIMBING.COM

KERSPLASH®POOL CLIMBING WALL INSTALLATION INSTRUCTIONS

ANCHORING THE CLIMBING WALL:

Anchoring should be done by an installer experienced with the use of 5/8”

Hilti Kwik Bolt3 (30455) anchoring systems. Hilti instructions for epoxy are

available from www.us.hilti.com or by calling 1.800.879-8000.

STEP 1) Prior to drilling and anchor install, read and follow Hilti recommended safety

precautions, and wear approved eye and ear protection.

STEP 2) There is a requirement of 6 anchoring brackets for the 16’ wall, 4 brackets

for the 12’ wall and 4 brackets for the 8’ wall. SEE FIGURE G

STEP 3) Mark or partially drill the holes following safety guidelines from Hilti. Move

the anchor brackets and ﬁnish drilling the holes as discussed in step 4.

STEP 4) Using a hammer drill and a 5/8” carbide hammer drill bit, drill the marked

holes to a minimum depth of 4”.

STEP 5) It is very important to remove the debris and dust from the borehole. Brush

the borehole with a steel brush that is slightly larger in diameter than the

borehole; twist out two times. Using compressed air, clean the borehole

again until the return stream is free of noticeable dust.

STEP 6) Reposition the anchoring bracket over the borehole and insert the threaded

anchor. Tighten to the Hilti recommended torque. SEE FIGURE H

STEP 7) Snap on the protective plastic caps over the exposed nuts and bolts.

PROPER ANCHORING ORDER FIGURE H

REQUIRED ANCHORING BRACKET POSITIONS | FIGURE G

8’ HIGH WALL |4 REQUIRED ANCHORING BRACKETS

12’ HIGH WALL |4 REQUIRED ANCHORING BRACKETS

16’ HIGH WALL |6 REQUIRED ANCHORING BRACKETS

FRONT BRACKETS

2 ANCHOR POINTS

REAR BRACKETS

2 ANCHOR POINTS

FRONT BRACKETS

2 ANCHOR POINTS

REAR BRACKETS

2 ANCHOR POINTS

FRONT BRACKETS

2 ANCHOR POINTS

REAR BRACKETS

2 ANCHOR POINTS

5/8” HILTI KWIK BOLT

9/16” X 4” DEEP HOLE

ANCHORING BRACKET

1-800-476-7366 | [email protected] |WWW.EVERLASTCLIMBING.COM

KERSPLASH®POOL CLIMBING WALL INSTALLATION INSTRUCTIONS

BONDING THE CLIMBING WALL:

Check state and local code for bonding requirements.

ADDITIONAL INSTRUCTIONS:

WARNING! Read all operating instructions before using the Kersplash

Pool Climbing Wall. Make sure that all individuals using the wall have

read and understand the Kersplash Climbing Wall Rules. Supervision

is required.

WARNING! Rock climbing indoors and outdoors is an inherently dangerous

sport. The activity of climbing can lead to signiﬁcant personal injury,

disﬁgurement or death. Even though one may be climbing indoors on an

artiﬁcial wall risks still exist. Artiﬁcial holds can spin, and on rare occasions

break. Individual climbers and organizations have the sole responsibility

for learning and using proper climbing technique and safety practices. The

purchasers and users of our products accept full and complete responsibility

for any and all damages or injury which may result from the use and/or

misuse of any product purchased from any EverActive™ Brands’ catalog, any

Everlast Climbing Marketing, and/or EVERLAST CLIMBING.

WARNING! This product may contain chemicals known to the State of

California to cause cancer and birth defects or other reproductive harm.

1-800-476-7366 | [email protected] |WWW.EVERLASTCLIMBING.COM

KERSPLASH®POOL CLIMBING WALL INSTALLATION INSTRUCTIONS

OPERATOR’S GUIDE

Safety Precautions:

•EverlastClimbingrecommendsthatalifeguardbeondutyatalltimes

when the Kersplash Pool Climbing Wall is in use. This may be required by

certain states; check your state and local codes to verify.

•NODIVINGisallowedoffoftheKersplashPoolClimbingWall.

•KersplashPoolClimbingWallusersmustbeabletoswim;werecommend

for ages 5 and above.

KERSPLASH CLIMBING WALL RULES

•SwimmersonlymayusetheKersplashClimbingWall;non-swimmersand

beginners should not use the wall.

•Swimmingabilityshouldbedeterminedbya25yardswimanda30

second treading exercise.

•Climbersmustread,understand,andobeyallpostedrules,instructions

and warnings.

•OnlyoneclimberisallowedontheClimbingWallatatime.

•Onlyfeet-rstentriesareallowedwhenenteringintothewater.

NO EXCEPTIONS!

•Noclimbingonthebackorsidesofthestructure.Climbonlyonthe

hand holds.

•ClimberswhointentionallyviolatetheNODIVINGruleWILLBEBANNED

from using the Kersplash Climbing Wall.

•Whenenteringthewater,kneesshouldbebentandarmsextendedfor

safety through increased deceleration.

•Theentranceandexitpathsdictatedbytheaquaticfacilitymustbefollowed.

•WhentheClimbingWallisopenforuse,alifeguardmustsupervisetheuse

of the structure without performing any other duties or observations.

•Climbersmaynotusethewallwithoutthedirectsupervisionofalifeguard

in close proximity of the structure.

•Climbersmustlistentoandobeythelifeguardsmonitoringthestructure.

•Climbmustbeginfromthewater.

•Divingmayresultinbodilyinjuryordeath.

•Swimawayfromtheclimbingwalldropzonewhenyouaredone

with your climb.

•Reportanydamagedequipmenttothesupervisor.

Table des matières

Manuels Équipement d'éclairage populaires d'autres marques

Brizo

Brizo 8SP-MU-4 Manuel utilisateur

LUCE&LIGHT

LUCE&LIGHT BROM 1.0 Manuel utilisateur

IKEA

IKEA BJÖRKSPIREA Manuel utilisateur

Laserworld

Laserworld Evolution Series ES-400RGB Manuel utilisateur

Alien

Alien RG STAR Manuel utilisateur

EuroLite

EuroLite LED B-40 Manuel utilisateur

Qazqa

Qazqa Suplux SL 3 Black 103062 Manuel utilisateur

Commercial Electric

Commercial Electric 54568141 Manuel utilisateur

CREE LIGHTING

CREE LIGHTING 304 Series Manuel utilisateur

Goobay

Goobay 49867 Manuel utilisateur

ECOMAN ITALIA

ECOMAN ITALIA LED T8 Manuel utilisateur

Alkalite

Alkalite Krypton KT-81 Manuel utilisateur

Clas Ohlson

Clas Ohlson GU10 Manuel utilisateur

DTS

DTS DELTA 10 F Manuel utilisateur

ring

ring Solar Steplight Manuel utilisateur

One Stop Gardens

One Stop Gardens 57696 Instructions de montage

Chauvet DJ

Chauvet DJ COREpar UV120 ILS Manuel utilisateur

SIREM

SIREM Swimeo A2 Manuel utilisateur