Endless Summer 233010 Manuel utilisateur

Owner’s

Manual

Model No.

233010

WARNING

FOR YOUR SAFETY:

For Outdoor Use Only

(outside any enclosure)

Solamente Para Uso En

Exteriores

(fuera de cualquier recinto)

1Owner’s manual and assembly instructions: model 233010 natural gas outdoor patio heater 1/14/03

Contact 1-800-762-1142 for assistance.

Do not return to place of purchase.

WARNING

FOR YOUR SAFETY:

If you smell gas -

1. Shut off gas to appliance.

2. Extinguish any open flame.

3. If odor continues, contact your gas

supplier or local fire department.

WARNING

FOR YOUR SAFETY:

• Improper installation, adjustment,

alteration, service or maintenance can

cause injury or property damage.

• Read the installation, operation, and

maintenance instructions thoroughly

before installing or servicing this

equipment.

• Failure to follow the manual’s

warnings and instructions can result

in severe personal injury, death, or

property damage.

• Fuel systems must be installed by

qualified and licensed personnel.

Improper installations present

hazards, which can lead to personal

injury or property damage. Please

contact your local Natural Gas

supplier for these services.

WARNING

FOR YOUR SAFETY:

Do not store or use gasoline or other

flammable vapors or liquids in the

vicinity of this or any other appliance.

WARNING

FOR YOUR SAFETY:

1. Gas leaks may cause a fire or explosion

which can cause serious bodily injury

or death, or damage to property.

2. You must follow all leak-checking

procedures as outlined in step 10

before operating this unit.

3. Never use an open flame to check

for leaks.

WARNING

FOR YOUR SAFETY:

Improper installation, adjustment,

alteration, service or maintenance

can cause injury or property damage.

Read the installation, operation and

maintenance instructions thoroughly

before installing or servicing this

equipment.

WARNING

FOR YOUR SAFETY:

For Outdoor Use Only

(outside any enclosure)

WARNING

FOR YOUR SAFETY:

• Purchaser assumes all risk in the

assembly and operation of this unit.

Failure to follow this manual’s

warnings and instructions can result

in severe personal injury, death or

property damage.

• Do not use in an explosive atmosphere.

Keep heater away from areas where

flammable liquids, gasoline, vapors, or

explosives are stored or used.

Owner’s manual and assembly instructions: model 233010 natural gas outdoor patio heater 1/14/03

Contact 1-800-762-1142 for assistance.

Do not return to place of purchase.

Table of Contents

Safety First! . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3

Assembly Instructions

Components & Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

General Components & Features . . . . . . . . . . . . . . . . . . . . . . . . . . .6

Additional Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

Step 1 Attach Legs to Base . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

Step 2 Attach Platform to Legs . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7

Step 3 Insert Gas Line Through Platform / Attach Cover . . . . . . . . .7

Step 4 Attach Engine to Post . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8

Step 5 Attach Engine/Post to Platform . . . . . . . . . . . . . . . . . . . . . . .8

Step 6 Connect Gas Line to Engine . . . . . . . . . . . . . . . . . . . . . . . . .9

Step 7 Assemble Dome . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9

Step 8 Attach Dome to Emitter . . . . . . . . . . . . . . . . . . . . . . . . . . . .10

Step 9 Secure Gas Line . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10

Step 10 Check for Leaks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11

Step 11 Replace Engine Access Panel . . . . . . . . . . . . . . . . . . . . . .12

Step 12 Install Igniter Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12

Operation

Before Turning Gas Supply ON . . . . . . . . . . . . . . . . . . . . . . . . . . . .13

Before Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13

Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

Re-Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14

Shutdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14

Operations Checklist . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15

Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16

Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17

Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18

Service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18

Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19

Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20

The use and installation of this product must conform to local codes. In

absence of local codes, us the National Fuel and Gas Code, ANSI Z223,

1/NFPA 54, Storage and Handling of Liquid Petroleum Gases,

ANSI/NFPA 58 or CSA B149.1, Natural Gas and Propane Installation

Code.

Save these instructions for

future reference.

If you are assembling this unit

for someone else, give

this manual to him or her to

save for future reference.

3Owner’s manual and assembly instructions: model 233010 natural gas outdoor patio heater 1/14/03

Contact 1-800-762-1142 for assistance.

Do not return to place of purchase.

Safety First!

Installation and repairs should be done by a qualified service person.

Read and become familiar with this entire manual, especially the following

precautions.

If you are unsure of anything in these instructions, STOP and contact

1-800-762-1142 for assistance.

Caution: This appliance is for outdoor use only (outside any

enclosure). Always make sure there is fresh air ventilation.

• Always maintain at least 36” clearance (top) and 24” clearance (side)

from combustible materials.

• Always place heater on a hard and level surface.

• Do not use if the wind velocity is greater than 10 miles per hour.

• Unit will operate at reduced efficiency below 40º F (5º C).

• It is normal for the heater to make a hissing sound at start-up. This will

decrease as the heater warms up.

• Keep sprinklers and other water sources away from burner and controls.

• Always use extreme caution when near heater. Alert both children and

adults to the hazards of high temperatures, especially to avoid burns or

clothing catching fire.

• Young children and pets should be carefully supervised when they are in

the area of heater.

• Do not hang clothing or other flammable materials either on or near heater.

• Certain materials or items, when stored under heater, will be subjected

to radiant heat and could be seriously damaged.

• Do not alter heater in any manner.

• Inspect heater before each use. If a damaged part is detected, do not

operate until an original equipment replacement part has been properly

installed. Use of unauthorized parts will void warranty and create an

unsafe condition.

• Prior to operating heater, replace any guards or protective devices

removed for servicing.

• During operation, do not touch burner assembly. The surface of heater’s

emitter can reach temperatures approaching 1600ºF.

WARNING

FOR YOUR SAFETY:

• Purchaser assumes all risk in

the assembly and operation of

this unit. Failure to follow this

manual’s warnings and

instructions can result in

severe personal injury, death

or property damage.

• Do not use in an explosive

atmosphere. Keep heater away

from areas where flammable

liquids, gasoline, vapors, or

explosives are stored or used.

Before you do anything else,

read and understand all

precautions in Safety First!

36"

Ceiling or Overhang

Wall

Owner’s manual and assembly instructions: model 233010 natural gas outdoor patio heater 1/14/03

Contact 1-800-762-1142 for assistance.

Do not return to place of purchase.

• After shutdown, do not touch burner assembly until heater has cooled

(approximately 45 minutes after use).

• The appliance and its individual shutoff valve must be disconnected from

the gas supply piping system during any pressure testing of that system

at test pressures in excess of 1/2 psig (3.5 kpa).

• The appliance must be isolated from the gas supply piping system by

closing its individual manual shutoff valve during any pressure testing of

the gas supply piping system at test pressures equal to or less than 1/2

psig (3.5 kpa).

• Always perform a leak test on gas connections whenever heater is

serviced. Never use a flame to test for leaks. Do not smoke while

performing a leak test.

Caution: It is essential to keep the heater’s valve compartment,

burners, and circulating air passages clean.

• Spiders and insects can create a dangerous condition that may damage

heater or make it unsafe. Keep burner area clean of all spiders, webs,

or insects.

• Inspect heater before each use.

• Have heater inspected annually by a qualified service person.

• Check heater immediately if any of the following conditions exist:

• The smell of gas in conjunction with extreme yellow tipping of

burner flames.

• Heater does not reach proper temperature.

Note: At temperatures less than 40º F, heat output will be reduced.

• Heater’s glow is excessively uneven.

• Burner makes popping noises during use.

Note: Aslight pop is normal when burner is extinguished.

• Carbon deposits may create a fire hazard. Keep dome and emitter clean

at all times.

• Do not clean heater with combustible or corrosive cleaners. Use warm,

soapy water.

• Do not paint engine, engine access panel or dome.

FOR YOUR SAFETY:

Beware of Spiders

Spiders or small insects can get into

the burner tube or other openings of

your heater, and spin webs or build

nests. These obstructions can lead to

gas flow problems. It is important to

make frequent inspections of these

areas and clean them when

necessary.

Before operating your heater for the

first time, be sure to check for

obstructions that may have occurred

during shipment.

5Owner’s manual and assembly instructions: model 233010 natural gas outdoor patio heater 1/14/03

Contact 1-800-762-1142 for assistance.

Do not return to place of purchase.

Components Hardware

Used in

Picture Qty Description Step(s)

12 Large Bolt 1 & 2

1Large Screw 2

4Medium Screw 4

3Dome Screw 7

12 Small Lockwasher 1 & 2

3Cap Nut 8

1Medium Nut 7

12 Small Nut 1 & 2

1 Clip 2

1 Finial 7

1Dome Bolt 7

1Hex Wrench 5

Owner’s manual and assembly instructions: model 233010 natural gas outdoor patio heater 1/14/03

Contact 1-800-762-1142 for assistance.

Do not return to place of purchase.

Assembly Instructions

General Components & Features

Familiarize yourself with all components before proceeding. Refer to page 5 for hardware and components, and page 20

for specifications.

The white ceramic cone in the top of the engine is an important piece. DO NOT REMOVE.

Do NOT attempt assembly unless all components are available. If you believe a component is missing or damaged,

contact 1-800-762-1142 for assistance.

Note: All hardware is mounted on a cardboard pack and numbered to match their assembly step.

Additional Requirements

The following items are not included, but are necessary for the proper assembly of your heater. Do NOT attempt to

assemble without proper tools. A hex (Allen) wrench is necessary and is included in the parts bag.

(1) 7/16” Wrench

(1) 7/16” Socket Wrench

(1) #2 Phillips Head Screwdriver

(1) Roll 3/8” Teflon plumbers tape

(1) Leak Detection Solution (Instructions on how to make solution are included in step 12)

Note: You must follow all steps to properly assemble heater.

Step 1 – Attach Legs to Base

• Secure Legs to Base using (2) Large Bolts, (2) Small lock washers

and (2) Small nuts per leg. Finger tighten only.

• Do not fully tighten until Step 2.

7Owner’s manual and assembly instructions: model 233010 natural gas outdoor patio heater 1/14/03

Contact 1-800-762-1142 for assistance.

Do not return to place of purchase.

Step 2 – Attach Platform to Legs

• Line up hole in Clip with small threaded hole on bottom of Platform.

• Attach Clip loosely to Platform with (1) Large Screw.

Note: Do not tighten until step 9.

• Using 7/16” wrench, secure Platform to Legs using (2) Large Bolts,

(2) Small Lock Washers and (2) Small Nuts per Leg. Tighten fully.

• Fully tighten all nuts and bolts from Step 1.

Step 3 – Insert Gas Line Through Platform / Attach

Cylinder Cover

• Insert Gas Line up through large hole in Platform from underneath

between center and left leg as shown in illustration.

• Slide Shroud Cover over Gas Line, then over Platform/Leg assembly

until bottom of Shroud rests on Base.

TIP:

To tighten use a 7/16” wrench on Bolt and a 7/16” socket wrench on Nut.

Note:

The fitting at end of gas line is 3/8 NPT female. Plumbing should be

done from this point according to local code.

Owner’s manual and assembly instructions: model 233010 natural gas outdoor patio heater 1/14/03

Contact 1-800-762-1142 for assistance.

Do not return to place of purchase.

Step 4 – Attach Engine to Post

• Lay Engine Assembly on its side, using large carton for support.

• Remove and save Control Knob.

• Remove and save Engine Access Panel by removing (1) black

Thumbscrew from bottom of Access Door.

• Disconnect wire from Igniter by gently pulling wire from back of box.

• Align (4) holes in top of Post with (4) holes in bottom of Engine.

Note: One hole is at a different level than the rest. Make sure that all 4

holes line up properly.

• Insert (4) Medium Screws enough to hold Engine in place. They will

be fully tightened at the end of Step 6.

Note: Do not replace Engine Access Panel until Step 12.

Step 5 – Attach Engine/Post to Platform

• Insert end of Post without holes over Gas Line, being careful not to

bend Gas Line.

• Slide Post into collar of Platform so Post rests completely on

Platform.

• Tighten bottom three setscrews with hex (Allen) wrench supplied.

• Make sure Post is perpendicular to Base.

• Use top three setscrews to adjust Post’s angle as necessary.

• Tighten all six setscrews.

Note: Post must be perpendicular to Base. Failure to do so will

adversely affect burner performance.

9Owner’s manual and assembly instructions: model 233010 natural gas outdoor patio heater 1/14/03

Contact 1-800-762-1142 for assistance.

Do not return to place of purchase.

Step 6 – Connect Gas Line to Engine

• Attach Gas Line to Control Valve:

• Pull collar of Gas Line back.

• Insert Gas Line over Control Valve.

• Release collar and it should lock in place. (Tip – push Gas Line up from

bottom of Post to make a good seating before releasing the collar.)

• Gently tug on line to test for proper connection. If Gas Line moves

you are not properly connected. Do not proceed until you have a

proper connection.

• Fully tighten the (4) screws from Step 4.

Step 9 – Assemble dome

Note: Each dome section has a pin mounted in place in the rolled

bottom edge. If necessary for proper alignment of dome sections,

loosen each screw prior to further assembly and retighten after sections

are aligned.

• With the large side facing up, slide a dome rib on to the same side

of one dome section as the pin. Slide two dome sections together,

allowing the exposed end of the pin slide into the rolled edge of the

next dome section. Line up hole in dome with threaded hole in pin.

• Insert one Dome Screw and secure loosely.

• Repeat procedure to complete the assembly of all three sections.

• Slide Dome bolt through bottom check plate (with small center

hump), being sure that the rolled edge faces down.

• Slide bolt from previous step through the center of the assembled

dome sections, and be sure that the rolled edge of the check plate

fits inside of the ends of the three Dome Ribs. Also be sure that the

slots in the check plate line up with the holes on the dome sections.

• Slide the other check plate over the Center bolt with the rolled edge

facing up, again making sure that the plate fits inside of the Ribs

and the holes line up with those in the dome.

• Spin the medium nut all the way down the bolt, clamping all of the

pieces in place, making sure that all of the humps fit inside one

another.

• Fully tighten all of the screws in the rolled edge.

• Slide Dome Cap over Dome Bolt, lining up notches in cap with

Dome Ribs. Thread on finial until tight.

Autres manuels pour 233010

Table des matières

Autres manuels Endless Summer Chauffage de terrasse

Endless Summer

Endless Summer GWT501A Manuel utilisateur

Endless Summer

Endless Summer 233000 Manuel utilisateur

Endless Summer

Endless Summer GWT801B Manuel utilisateur

Endless Summer

Endless Summer GWU501E Manuel utilisateur

Endless Summer

Endless Summer EWU710SP Manuel utilisateur

Endless Summer

Endless Summer EWTR800SP Manuel utilisateur

Endless Summer

Endless Summer EWT700SP Manuel utilisateur

Endless Summer

Endless Summer EWTR89SP Manuel utilisateur

Endless Summer

Endless Summer 92000 Manuel utilisateur

Endless Summer

Endless Summer 233000 Manuel utilisateur

Endless Summer

Endless Summer EWUR730SP Manuel utilisateur

Endless Summer

Endless Summer Endless Summer EWUR810SP Manuel utilisateur

Endless Summer

Endless Summer 233010 Manuel utilisateur

Endless Summer

Endless Summer 92000 Manuel utilisateur

Endless Summer

Endless Summer Endless Summer EWTS830SP Manuel utilisateur

Endless Summer

Endless Summer ENDLESS SUMMER EWTR720SP Manuel utilisateur

Endless Summer

Endless Summer 200209 Manuel utilisateur

Endless Summer

Endless Summer GWT501A Manuel utilisateur

Endless Summer

Endless Summer 153100 Manuel utilisateur

Endless Summer

Endless Summer 233000 Manuel utilisateur

Endless Summer

Endless Summer EWTR850SP Manuel utilisateur

Endless Summer

Endless Summer ES4000COMM Manuel utilisateur

Endless Summer

Endless Summer EWTR890SP Manuel utilisateur

Endless Summer

Endless Summer ES5000COMM Manuel utilisateur

Manuels Chauffage de terrasse populaires d'autres marques

empasa

empasa HMXD-E-NHS Manuel utilisateur

Sunred

Sunred Indus Manuel utilisateur

HEAT1

HEAT1 ECO pro-line 2300W Manuel utilisateur

Heatmaxx

Heatmaxx SRPH98 Manuel utilisateur

Sunjoy

Sunjoy A30600640 Manuel utilisateur

Event Furniture

Event Furniture 16091 Guide de dépannage

Prem-I-Air

Prem-I-Air EH1462 Manuel utilisateur

Blumfeldt

Blumfeldt 10028637 Manuel utilisateur

Sunjoy

Sunjoy L-PH011PSS-2 Manuel utilisateur

Melissa

Melissa 670-202 Manuel utilisateur

Quality Heating

Quality Heating THE-12DW Manuel utilisateur

DCS

DCS PHFS-P4 Guide d'installation

EUROM

EUROM 334241 Manuel utilisateur

Lava Heat

Lava Heat Venetian Manuel utilisateur

EHS Ltd.

EHS Ltd. HQH-2000W Manuel utilisateur

VONROC

VONROC ALICUDI PH515AC Manuel utilisateur

OZONA

OZONA Heatflow IF010997 Manuel d'exploitation et d'entretien

theBBQshop

theBBQshop 51611010 Guide de configuration