Empire Comfort Systems VFS32FB0F-5 Guide de démarrage rapide

Page 1

UNIVERSAL FIREBOX FOR

ALL VENT-FREE LOG SETS

MODELS

VFS(32,36,42)FB0F-5

VFS(36,42)FB2HF-5

INSTALLATION INSTRUCTIONS

AND OWNER'S MANUAL

Select Vent-Free Universal Fireboxes

GAS-FIRED

EMPIRE

Comfort Systems

Installer: Leave this manual with the appliance.

Consumer: Retain this manual for future reference.

FOR USE ONLY WITH A LISTED GAS-FIRED

UNVENTED DECORATIVE ROOM HEATER NOT TO EX-

CEED 40,000 BTU/H.

DO NOT BUILD A WOOD FIRE.

WARNING: Improper installation, adjustment, altera-

tion, service or maintenance can cause injury or property

damage. Refer to this manual. For assistance or additional

information, consult a qualied installer, service agency or

the gas supplier.

Carefully review the instructions supplied with the decora-

tive type unvented room heater for the minimum replace

size requirement.

DO NOT INSTALL A VENT-FREE LOG SET IN THIS FIREBOX,

UNLESS THIS FIREBOX MEETS THE MINIMUM DIMENSIONS

REQUIRED FOR THE INSTALLATION.

ANSI Z21.91 Ventless Fireplace Enclosures for Gas Fired

Decorative Type Unvented Room Heaters

WARNING: If the information in these instructions are not

followed exactly, a re or explosion may result causing

property damage, personal injury or loss of life.

— Do not store or use gasoline or other ammable vapors

and liquids in the vicinity of this or any other appliance.

— WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use any

phone in your building.

• Immediately call your gas supplier from a neigh-

bor’s phone. Follow the gas supplier’s instruc-

tions.

• If you cannot reach your gas supplier, call the re

department.

— Installation and service must be performed by a quali-

ed installer, service agency or the gas supplier.

DO NOT ATTEMPT TO MODIFY OR ALTER THE CONSTRUC-

TION OF THE FIREBOX OR ITS COMPONENTS. ANY MODI-

FICATION OR ALTERATION OF CONSTRUCTION MAY VOID

THE WARRANTY OF THIS FIREBOX.

CHILDREN AND ADULTS SHOULD BE ALERTED TO THE

HAZARDS OF HIGH SURFACE TEMPERATURE AND

SHOULD STAY AWAY TO AVOID BURNS OR CLOTHING IG-

NITION.

YOUNG CHILDREN SHOULD BE CAREFULLY SUPERVISED

WHEN THEY ARE IN THE SAME ROOM AS THE FIREBOX.

33743-2-0315Page 2

TABLE OF CONTENTS

IMPORTANT SAFETY INFORMATION ............................................................................ 3

INTRODUCTION .............................................................................................................. 3

CLEARANCES............................................................................................................. 4 - 5

FIREBOX INSTALLATION INSTRUCTIONS ............................................................... 6 - 8

INSTALLING HOOD..................................................................................................... 8 - 9

GAS LINE CONNECTION ................................................................................................ 9

OPTIONAL FRESH AIR KIT INSTALLATION INSTRUCTIONS .............................. 10 - 12

OPTIONAL FBB5 SINGLE SPEED BLOWER INSTALLATION INSTRUCTIONS... 13 - 15

JUNCTION BOX WIRING INSTALLATION INSTRUCTIONS......................................... 16

MAINTENANCE.............................................................................................................. 16

MASTER PARTS DISTRIBUTOR LIST........................................................................... 17

HOW TO ORDER REPAIR PARTS................................................................................. 17

PARTS LIST.................................................................................................................... 18

PARTS VIEW .................................................................................................................. 19

ACCESSORIES ....................................................................................................... 20 - 21

WARRANTY.................................................................................................................... 22

APPLIANCE SERVICE HISTORY .................................................................................. 23

SECTION PAGE

33743-2-0315 Page 3

The installation must conform with local codes or, in

the absence of local codes, with the National Fuel Gas

Code, ANSI Z223.1 (latest edition) and to the National

electrical Code, ANSI/NFPA70 (latest edition).

NOTE: Installation and repair should be done by a quali-

ed service person. The appliance should be inspected

before use and at least annually by a qualied service

person. More frequent cleaning may be required due

to excessive lint from carpeting, bedding material, etc.

It is imperative that control compartment, burners and

circulating air passageways of the appliance be kept

clean.

Any safety screen or guard removed for servicing an

appliance must be replaced prior to operating the appli-

ance. Provide adequate combustion and ventilation air.

The ow of combustion and ventilation air MUST NOT

be obstructed.

Provide adequate clearance around air openings into

the combustion chamber and adequate accessibility

clearance for servicing and proper operation. NEVER

obstruct the front opening of the appliance.

This Empire Comfort Systems, Inc. rebox and its

components have been tested and will operate safely

when installed in accordance with this installation

manual. Read all instructions before starting installation,

then follow these instructions carefully during

installation to maximize rebox benet and safety.

Report to your dealer any parts damaged in shipment.

The Empire Comfort Systems, Inc. warranty will be

voided by, and Empire Comfort Systems, Inc. disclaims

any responsibility for the following actions:

- Installation of any damaged rebox.

- Modication of the rebox or any of the components

parts thereof.

- Installation other than as instructed by Empire

Comfort Systems, Inc.

- Installation and/or use of any component part

or accessory not approved by Empire Comfort

Systems, Inc. in combination or assembly with

a Empire Comfort Systems, Inc. firebox, not

withstanding any independent testing laboratory

or other third party approval of such component

part or accessory.

Any such action may create a possible re hazard.

Consult your local building codes.

Firebox Screen.

The rebox screen must be in place when the rebox

is operating.

Instructions to Installer

1. Installer must leave instruction manual with owner after

installation.

2. Installermusthaveownerlloutandmailwarrantycard

suppliedwithrebox.

3. Installershouldshowownerhowtostartandoperate

logsetthatisinstalledintorebox.

Important

AllcorrespondenceshouldrefertocompleteModelNumber,

Serial Number.

Notice: During initial ring of this rebox with a log set

installed,itspaintwillbakeout,andsmokewilloccur.To

preventtriggeringofsmokealarms,ventilatetheroomin

whichtheunitisinstalled.

Qualied Installing Agency

Installationandreplacementofgaspiping,gasutilization

equipment or accessories and repair and servicing of

equipmentshallbeperformedonlybyaqualiedagency.

The term "qualied agency" means any individual, rm,

corporationorcompanywhicheitherinpersonorthrough

arepresentativeisengagedin and is responsible for(a)

the installation or replacement of gas piping or (b) the

connection,installation, repair or servicing of equipment,

whoisexperiencedinsuchwork,familiarwithallprecautions

requiredandhascompliedwithalltherequirementsofthe

authorityhavingjurisdiction.

StateofMassachusetts:Theinstallationmustbemade

byalicensedplumberorgastterintheCommonwealth

of Massachusetts. The state of Massachusetts requires

thataexibleapplianceconnectorcannotexceedthree

feet in length.

Sellers of unvented propane or natural gas-fired

supplemental room heaters shall provide to each

purchaseracopyof527CMR30uponsaleoftheunit.

IntheStateofMassachusetts,unventedpropaneand

natural gas-red space heaters shall be prohibited in

bedroomsandbathrooms.

The installation must conform with local codes or, in the

absenceoflocalcodes,withtheNationalFuelGasCode,

ANSI Z223.1/NFPA 54.*

*AvailablefromtheAmericanNationalStandardsInstitute,

Inc.,11West42ndSt.,NewYork,N.Y.10036.

IMPORTANT SAFETY INFORMATION

INTRODUCTION

33743-2-0315Page 4

Sidewall Clearances:Theclearancefromtheinsideoftherebox

toperpendicularcombustiblesidewallshouldnotbelessthan

6 inches. See Figure 1.

Firebox Side and Back Clearances:Thereboxoutercasingside

andbackangesarezeroclearancetocombustibles.

Top Framing and Finishing: Combustible nishing materials

requires 3/4 inch to top of unit. There are two shoulder bolts

attached to the unit to maintain the minimum clearance. See

Figures 2 and 3.

CLEARANCES

Figure 1

Figure 2 - Louvered Models

Figure 3 - Flush Models

33743-2-0315 Page 5

Ceiling Clearances: The ceiling height should not be less than

84inchesfromthebottomoftherebox.See Figure 4.

Mantel Clearances: Ventfreereboxmodelsmustusethehood

suppliedwiththerebox,oroneoftheoptionalhoodkitsavailable

foreachmodel.Ifacombustiblemantelisinstalled,itmustmeet

theclearancerequirementsdetailedbelow.

Leaveatleast36inchesclearancefromthefrontoftherebox.

Figure 4 - Clearances to Combustibles

CLEARANCES

33743-2-0315Page 6

Vent-Free Firebox Framing Dimensions (in inches)

ABC

Model Framing Height FramingWidth Framing Depth

VFS32FB 38-7/8 35-3/8 23-3/8

VFS36FB 38-7/8 40-3/8 23-3/8

VFS42FB 38-7/8 44-3/8 23-3/8

Attention:Add3-3/4inchesto"A"Dimensionwhenusingushmantelbase.

Anyvent-freeGasLogHeatermustbe“ForusewithapprovedANSI

Z21.11.2unventedroomheater.”

Followandcompletetheinstallationinstructionsofthegaslogset

andtherequirementsofthisrebox.

Checkallttingsforleaksbeforelightingthegaslogset.

Inplanningtheinstallationfortherebox,itisnecessarytodetermine

wheretheunitistobeinstalledandwhetheroptionalaccessories

aredesired.Gassupplypipingshouldalsobeplannedatthistime.

A gas shut off must be in this line.

Thereboxcanbemountedonanyofthesesurfaces:

1. Aathardcombustibleornon-combustiblesurface.

2. Araisedplatformofcombustibleornon-combustiblematerial.

3. Recessedintotheoorasillustratedby Figure 5.

4. Supportedunderallfourcornersofthereboxsothatcontact

ismadeonallfourperimeteredgesonthebottomoftheunit

(Example:Fourconcretemasonryblocks).

Ifthereboxisinstalleddirectlyoncarpeting,tileorothercombustible

materialotherthanwoodooring,itshouldbeinstalledonametal

orwoodpanelextendingthefullwidthanddepthoftheunit.

Atthispoint,youshouldhavedecidedwhatcomponentstoinclude

inyourinstallation,andwherethereboxistobelocated.Ifthis

hasnotbeen done, stop andconsult your dealer forassistance

with this planning.

Planning Your Installation

PleasenotethattheoptionalVFA2FreshAirkitavailableforuse

withtheVentFreeFireboxmustbeinstalledatthetimeoftheinitial

installation.Refertopages10,11and12fordetailedinstructions

fortheairkit.

AccessorykitssuchastheFBB5Blowerkit,Trimkits,Mantels,Full

Cabinet Mantels, plus other Decorative Frame, Hood, and Door

accessorykitsmaybeinstalledafterthereboxissecuredtothe

framedopening.

Refertotheinstructionsprovidedwitheachoftheoptionalaccessory

kitsforproperinstallationandoperation.

Firebox Framing

Fireboxframingcanbebuiltbeforeorafterthereboxissetinplace.

Framingshouldbepositionedtoaccommodatewallcoveringand

reboxfacingmaterial.Thereboxframingshouldbeconstructed

of2x4lumberorheavier.Theframingheadersmayrestonthe

topofthereboxstandoffs.RefertoFigures 6 and 7forrebox

framingdimensions.

Figure 4

Figure 6

FIREBOX INSTALLATION INSTRUCTIONS

33743-2-0315 Page 7

Figure 7

Firebox Dimensions

FIREBOX INSTALLATION INSTRUCTIONS

OUTER FIREBOX DIMENSIONS

INNER FIREBOX DIMENSIONS

TOP VIEW SIDE VIEW

OUTER FIERBOX DIMENSIONS

(in inches)

INNER FIERBOX DIMENSIONS

(in inches)

FLUSH WITHOUT BRICK

INDEX

LETTER VFS32 VFS36 VFS42 INDEX

LETTER VFS32 VFS36 VFS42

A 38-1/16 38-1/16 38-1/16 A 31 36 40

B 34-1/4 39-1/4 43-1/4 B 23-1/2 28-1/2 32-1/2

C 23-3/16 23-3/16 23-3/16 C 18-1/8 18-1/8 18-1/8

D 25-1/16 30-1/16 34-1/16 D 29-1/8 29-1/8 29-1/8

E - - - E 31-1/2 31-1/2 31-1/2

F 31 36 40

G 31-5/8 31-5/8 31-5/8

H 2 2 2

I 33-5/8 33-5/8 33-5/8

J - - -

K 7-9/16 7-9/16 7-9/16

L 40-7/16 42-15/16 44-15/16

M 70-15/16 75-15/16 79-15/16

N 4-1/4 4-1/4 4-1/4

33743-2-0315Page 8

Locating Firebox

Placereboxinframingopening.Usethetabsonthesideofthe

reboxtoattachreboxtoframing.Differenttablocationscanbe

usedfornishingmaterialswiththicknessesof1/2inchand5/8inch.

See Figure 8.

Framingtabsshould t directly againstframingmaterial. Use at

leastonenailperbrackettosecureinplace.

Checksquarenessofthereboxpriortosecuringtoframedopening.

See Figure 9.

Figure 8

Ablackhoodthatisfurnishedwitheachrebox(oroptionalhood)

MUST be installed before the rebox is used. Failure to do so

may create a possible re hazard. The hood is located behind

upper louver, or inside the rebox on ush face units. If brass,

stainlesssteel,orhammeredpewterhoodsaredesired,theycan

bepurchasedasanoption.Attachmentisthesameasthestandard

blackhood.

Flush Face Models

1. Onushfacemodels,looselyattachtwoscrews(A)toholdthe

reboxtoptofacepanel,thenslidethehoodangebetweenthe

reboxtopandfacepanelandre-tightenthescrews.

2. Installonescrewateachendofthehoodasshown(C).

Louvered Models

1. Ifyouhavealouveredmodel,removeupperlouver.

2. Placethetophoodangeontopoftherebox,theninstallthree

screwsthroughthereboxtopfrombelowandscrewintothe

pilotholesinthehoodange(B).

3. Installonescrewateachendofthehoodasshown(C).

4. Re-install louver.

Caution:Thehoodmustbeinstalledpriortooperationofappliance.

See Figure 10

Flush Face Models

Figure 10

Figure 9

FIREBOX INSTALLATION INSTRUCTIONS

INSTALLING HOOD

INNER FIREBOX TOP

Louvered Models

ACAC

33743-2-0315 Page 9

Thereboxisdesignedtoaccepta3/8-inchgaslineforanapproved

vent-freegaslogset.Havethelineinstalledbyaqualiedservice

personinaccordancewithallbuildingcodes.Consultlocalbuilding

codestoproperlysizethegassupplylineleadingtothe3/8-inch

hook-up at the unit. The state of Massachusetts requires that a

exibleapplianceconnectorcannotexceedthreefeetinlength.

Gasaccessholesareprovidedonbothsidesoftherebox.See

Figure 11.

When installing optional ceramic ber side panels into rebox,

laypanelonaatsurface.Removethegaslineknockout(round

depression)intheappropriatesidepanelusingadrillorutilityknife.

Checkgastype.Useonlythegastypeindicatedonthegaslog

setratingplate.Ifthegaslistedontheplateisnotyourtypeofgas

supply,DONOTINSTALL.Contactyourdealerforpropermodel.

AlwaysuseanexternalregulatorforallLPreboxestoreducethe

supplytankpressuretoamaximumof14inchw.c.Thisisinaddition

totheregulatorttedtothelogset.

WARNING: CONNECTION DIRECTLY TO AN UNREGULATED

L.P. TANK CAN CAUSE EXPLOSION.

InstallonlyaANSIZ21.11.2vent-freeburnerandlogsetintothis

rebox.

Figure 11

Extended Hoods

Ifyournon-combustiblefacingmaterialisover1"inthicknessthatwillbeusedtonishthisrebox,anextendedhoodisavailablethatwill

extendout2"fartheroutintotheroom.Contactyourlocaldealerfordetails.

Finishing

Alljoints(top,bottomandsides),wherethewallordecorativefacingmaterialmeetsthereboxsurroundshouldbesealedwithanon-

combustible material.

Hearthextensionsarerecommended,butnotrequiredforthesereboxes.

VB4H32BL StandardBlack VB4H36BL StandardBlack VB4H42BL StandardBlack

VB4H32BR PolishedBrass VB4H36BR PolishedBrass VB4H42BR PolishedBrass

VB4H32SS Stainless Steel VB4H36SS Stainless Steel VB4H42SS Stainless Steel

VB4H32HP HammeredPewter VB4H36HP HammeredPewter VB4H42HP HammeredPewter

INSTALLING HOOD

GAS LINE CONNECTION

Brick Panel

Figure 12

GAS ACCESS HOLES

33743-2-0315Page 10

OPTIONAL FRESH AIR KIT INSTALLATION INSTRUCTIONS

Figure 15

Figure 16

4. Fasten the Handle Retainer to the rebox side with two

10x1/2PhillipsTrussHeadScrewsasshowninFigure 16.

TheoptionalFreshAirKitisdesignedtointroduceoutsideairto

thereboxasdesired.

Itmustbeinstalledpriorto,oratthetimeofreboxinstallationto

framing.

TheFreshAirkitmustbeinstalledpriortotheinstallationofwall-

boardorothernishingmaterialsaroundtheunit.

Hardware needed (not provided): 4 inchAluminum Flex Duct,

2BandClamps

Tools needed: Gloves,Metalsnips,5/16inchNutDriver,

PhillipsScrewdriver

Caution: Sharp edges

SlideAssemblyInstallation

1. Beginbyremovingtherectangularcutoutlocatedontheleft

sideoftheunit.Useglovesandsheetmetalsnipstocreate

theopeningfortheAirDoorassemblytoinstallinto.SeeFig-

ure 13.

Figure 13

2. Bendthetaboutoftheway. See Figure 14.

Figure 14

3. InsertSlideAssemblythroughthecut-outasshowninFigure

15.Beforeyoufastenensurethatthehandlepenetratesthe

innerreboxwall.See Figure 16.FastentheSlideAssembly

withthefour10x1/2HexHeadScrewsprovided.

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels Empire Comfort Systems Cheminée intérieure

Empire Comfort Systems

Empire Comfort Systems MILLIVOLT VFPA32BP30LN-1 Guide de démarrage rapide

Empire Comfort Systems

Empire Comfort Systems Boulevard VFLL60FP90LP-1 Manuel utilisateur

Empire Comfort Systems

Empire Comfort Systems DVCP32BP30N-1 Guide de démarrage rapide

Empire Comfort Systems

Empire Comfort Systems Tahoe DVP36PP32EN-1 Guide de démarrage rapide

Empire Comfort Systems

Empire Comfort Systems DVL36BP30 Series Manuel utilisateur

Empire Comfort Systems

Empire Comfort Systems Tahoe Premium DVP36PP32EN Guide de démarrage rapide

Empire Comfort Systems

Empire Comfort Systems DVCP36PP30 Series Guide de démarrage rapide

Empire Comfort Systems

Empire Comfort Systems LSU24RR-2 Guide de démarrage rapide

Empire Comfort Systems

Empire Comfort Systems DVCT30CBN95N-2 Manuel utilisateur

Empire Comfort Systems

Empire Comfort Systems OP36FP32MN-3 Guide de démarrage rapide

Empire Comfort Systems

Empire Comfort Systems White Mountain Hearth DVCX42FP91K-3 Guide de démarrage rapide

Empire Comfort Systems

Empire Comfort Systems VFP32FB0L Guide de démarrage rapide

Empire Comfort Systems

Empire Comfort Systems VFP32FB Series Guide de démarrage rapide

Empire Comfort Systems

Empire Comfort Systems VFLL48SP(3 Guide de démarrage rapide

Empire Comfort Systems

Empire Comfort Systems DVX36DP31N-2 Guide de démarrage rapide

Empire Comfort Systems

Empire Comfort Systems DVCD32FP30P-1 Guide de démarrage rapide

Empire Comfort Systems

Empire Comfort Systems ONR-24-1 Guide de démarrage rapide

Empire Comfort Systems

Empire Comfort Systems VFL20IN3 series Guide de démarrage rapide

Empire Comfort Systems

Empire Comfort Systems VFLL38FP30LN-1 Guide de démarrage rapide

Empire Comfort Systems

Empire Comfort Systems DVP36PP32EN-4 Manuel utilisateur

Empire Comfort Systems

Empire Comfort Systems Boulevard LS41THF-1 Guide de démarrage rapide

Empire Comfort Systems

Empire Comfort Systems DVP36FP3 series Guide de démarrage rapide

Empire Comfort Systems

Empire Comfort Systems OP32FB2MF-1 Manuel utilisateur

Empire Comfort Systems

Empire Comfort Systems Boulevard LS41TDF-1 Guide de démarrage rapide

Manuels Cheminée intérieure populaires d'autres marques

Brigantia

Brigantia 35-DVRS31N-2 Manuel du propriétaire

Nordpeis

Nordpeis Bergen Manuel utilisateur

Superior

Superior BCT2536TMN Manuel utilisateur

Quadra-Fire

Quadra-Fire 5100I-GD-B Manuel utilisateur

Renaissance

Renaissance RUMFORD 1000 Manuel utilisateur

Lacunza

Lacunza IV-800 Manuel utilisateur

Baxi

Baxi 940 Instructions d'utilisation

Dru

Dru Maestro 60/2 Tall RCH Manuel utilisateur

Diamond Fireglass

Diamond Fireglass SS-O22 Manuel utilisateur

HearthStone

HearthStone Windsor Bay 8830 Manuel de programmation

Napoleon

Napoleon ASCENT B42 Manuel utilisateur

Enviro

Enviro E33GI Manuel utilisateur

Smeg

Smeg L30 FABE Instructions de montage

KEDDY

KEDDY K700 Manuel utilisateur

Godin

Godin 3451 Manuel utilisateur

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Manuel utilisateur

Austro Flamm

Austro Flamm Heidi Back 2.0 945048 Manuel utilisateur

Desa

Desa CCFPDFT Manuel d'utilisation