Emerson Bettis RP4AF Manuel utilisateur

Bettis RTS Relay Board (RP4AF)

Electric Actuator

Installation, Operation and Maintenance Manual

VCIOM-15749-EN Rev. 0

June 2021

Revision Details

June 2021

Installation, Operation and Maintenance Manual

VCIOM-15749-EN Rev. 0

Revision Details

No. Date Version Type of Change

1 June 2021 0 General update

(Migration to new template)

Revision Details

Table of Contents

June 2021

Installation, Operation and Maintenance Manual

VCIOM-15749-EN Rev. 0

Table of Contents

Section 1: Tools

Tools.........................................................................................................................1

Section 2: Material

Material.....................................................................................................................2

Section 3: Installation

Installation................................................................................................................3

Section 4: Programming

Programming............................................................................................................7

Notes

June 2021

Installation, Operation and Maintenance Manual

VCIOM-15749-EN Rev. 0

This page is intentionally left blank

June 2021

Installation, Operation and Maintenance Manual

VCIOM-15749-EN Rev. 0

1Tools

Section 1: Tools

! WARNING

Remove all power supplies before doing the exchange. Act always with caution during

the exchange!

• Needle nose pliers

• Screw driver phillips

• Screw driver at

• Allen key 5

• Socket wrench 5

Figure 1

June 2021

Installation, Operation and Maintenance Manual

VCIOM-15749-EN Rev. 0 Rev. 0

2Material

Section 2: Material

• 1x relay board RP4AF (ID:15772)

• 2x steel screw M3x16 (ID:952)

• 3x plastic distance 8 mm (ID:9896)

• 1x plastic screw M3x15 (ID:9895)

• 1x plastic nut M3 (ID:7084)

• 2x lock plates M3 red (ID:13674)

Figure 2

Figure 3

June 2021

Installation, Operation and Maintenance Manual

VCIOM-15749-EN Rev. 0

3Installation

Section 3: Installation

Unscrew the 4 hexagon socket screws from the cover and remove it carefully. Mind the

connection cable between display and logic board.

Figure 4

Unscrew the 4 cross recessed screws from the existing logic board and afterwards tilt it

carefully to you.

Figure 5

June 2021

Installation, Operation and Maintenance Manual

VCIOM-15749-EN Rev. 0 Rev. 0

4Installation

Section 3: Installation

Remove the cable with the 10-pole connector and connect it with the relay board.

Figure 6

Insert plastic screw M3x15 in provided hole and add plastic distance on it, after connect the

relay board with the logic board on suitable connector. Add plastic nut on plastic screw to

x the board.

Figure 7

June 2021

Installation, Operation and Maintenance Manual

VCIOM-15749-EN Rev. 0

5Installation

Section 3: Installation

Put two plastic distances 8 mm between logic and relay board, insert the M3x16 steel

screws through the estimated holes in logic board, plastic distances and relay board and

secure the screws with the red lock plates.

Figure 8

Install die logic + relay board back to the control (two small screws for original installation

will remain). Take care of possible damage of cables or other parts.

Figure 9

June 2021

Installation, Operation and Maintenance Manual

VCIOM-15749-EN Rev. 0 Rev. 0

6Installation

Section 3: Installation

Connect cable between display cover and logic board. Perform a Firmware update now,

before installing display cover on the unit. This update is important for the following

programming steps (use FW version display 1507, logic 219 or higher). For a detailed

description on how to perform a rmware update, please refer to separate manual.

During display cover installation, pay attention to the O-ring which must be sit correct

between cover and housing and x it with the 4 hexagon socket screws.

Figure 10

Autres manuels pour Bettis RP4AF

Table des matières

Autres manuels Emerson Contrôleurs

Emerson

Emerson EL-O-MATIC EL35 Manuel utilisateur

Emerson

Emerson Bettis Q series Manuel d'instructions

Emerson

Emerson PACSystems RX3i Manuel utilisateur

Emerson

Emerson Fisher 161 Series Manuel utilisateur

Emerson

Emerson E2 Manuel utilisateur

Emerson

Emerson Fisher 1052 Guide de l'utilisateur

Emerson

Emerson Unidrive M700 Manuel utilisateur

Emerson

Emerson Fisher FIELDVUE DVC6200 HW2 Guide de configuration

Emerson

Emerson EXD-HP1/2 Manuel utilisateur

Emerson

Emerson EL-O-Matic F-Series Guide de l'utilisateur

Emerson

Emerson Dixell XR64CX Schéma de câblage

Emerson

Emerson Dixell XR70CH Schéma de câblage

Emerson

Emerson Dixell iChill IC200D EVO Series Schéma de câblage

Emerson

Emerson Fisher easy-Drive 200L Manuel utilisateur

Emerson

Emerson SW81 Manuel utilisateur

Emerson

Emerson F-Series Manuel utilisateur

Emerson

Emerson fisher 1008 Manuel utilisateur

Emerson

Emerson Bettis XTE3000 Manuel utilisateur

Emerson

Emerson Yarway Manuel utilisateur

Emerson

Emerson Dixell XF330M Schéma de câblage

Emerson

Emerson FISHER 627W Manuel utilisateur

Emerson

Emerson Copeland EV2 Series Guide de l'utilisateur

Emerson

Emerson EC3-D72 Manuel utilisateur

Emerson

Emerson Fisher 1051 Manuel utilisateur

Manuels Contrôleurs populaires d'autres marques

Digiplex

Digiplex DGP-848 Mode d'emploi

YASKAWA

YASKAWA SGM series Manuel utilisateur

Sinope

Sinope Calypso RM3500ZB Manuel utilisateur

Isimet

Isimet DLA Series Style 2 Manuel d'installation

LSIS

LSIS sv-ip5a Manuel utilisateur

Rockwell Automation

Rockwell Automation 1769-L31 Manuel utilisateur

Airflow

Airflow Uno hab Manuel utilisateur

ABB

ABB ACS580-01 drives Manuel utilisateur

Panasonic

Panasonic GM1 Series Manuel utilisateur

AutoAqua

AutoAqua Smart ATO micro SATO-120P Manuel utilisateur

Panasonic

Panasonic FP? Positioning Unit RTEX Manuel utilisateur

Samson

Samson Type 5824 Manuel de service

Alpha IP

Alpha IP MIOB 21001 Manuel utilisateur

Siemens

Siemens OpenAir GMA 1 Series Manuel utilisateur

Surecom

Surecom SR-629 Manuel utilisateur

Fishman

Fishman TriplePlay Manuel utilisateur

Regulus

Regulus SRS1 T Manuel utilisateur

3M MicroTouch EX113 Manuel utilisateur