Cellar Cool ACH 550 Manuel utilisateur
ACH 033114
TECH/OWNERS MANUAL
ACH 033114
Copyright © 2012. CellarCool. All rights reserved.
This manual, the product design, and the design concepts are copyrighted by CellarCool, with all rights reserved. Your rights with
regard to the hardware and manual are subject to the restrictions and limitations imposed by the copyright laws of the United
States of America. Under copyright laws, this manual may not be copied, reproduced, translated, transmitted, or reduced to any
printed or electronic medium or to any machine-readable form, for any purpose, in whole or in part, without the written consent
of CellarCool.
Every eort has been made to ensure that the information in this manual is accurate. CellarCool is not responsible for printing or
clerical errors.
CellarCool reserves the right to make corrections or improvements to the information provided and to the related hardware at any
time, without notice.
Vinothèque and CellarCool are registered trademarks, and ECE is a trademark of CellarCool. All rights reserved.
Mention of third-party products is for informational purposes only and constitutes neither an endorsement nor a
recommendation. CellarCool assumes no liability with regard to the performance or use of these products.
03.31.14
www.cellarcool.com | Page 1
TABLE OF CONTENTS
Quick Reference Guide
System ..................................................
Specications ............................................
Introduction ................................................
Receiving & Inspecting The System .........................
Before You Start ............................................
Unobstructed Airow.......................................
Active Humidity Option Overview ..........................
Installing the ACH 550 Humidier ..........................
Humidistat Installation .....................................
Installing the ACH 550 Humidier Continued ..............
Installing the Drain Line ....................................
Maintenance Schedule .....................................
Troubleshooting Guide .....................................
Technical Assistance & Accessories .........................
Installation Terms and Conditions ..........................
2
3
4
5
6
7
8
9
10
12
13
14
15
16
17
ACH 033114
Page 2 | 1-855-235-5271
QUICK REFERENCE GUIDE
Wall Mounted ACH 550 Humidier Front / Side View
Humidier Rear / Side View
Top Access Panel
Drain Line
Connection
Power Cord
Humidistat
Connection
Water Port
Mounting Key Holes
www.cellarcool.com | Page 3
ACH 550 SPECIFICATIONS
Model ACH 550
Dimensions 14 7/16”w x 7 1/8”d x 8 3/16”h
Power Consumption 0.2 amps @ 120V/60 Hz
Weight (lbs) 9
dBA TBD
Drainline 1/2”
Humidistat Range 30-90% RH
Humidistat Accuracy ± 1%
Humidistat Adjustment
Increments 1%
Water Supply Feed Rate 0.63 gph @ 40 psi
Humidistat Digital Control Display
Warranty 2 year parts and labor
ACH 033114
Page 4 | 1-855-235-5271
Mail to:
CellarCool
ATTN: Warranty Registration
1738 E. Alpine Avenue
Stockton, CA 95205-2505
USA
Fax to:
209.466.4606
Scan and email to:
warranty@cellarcool.com
OR OR
INTRODUCTION
Customer Service
Thank you for purchasing a CellarCool humidifying system. We strive to provide the highest quality products and the
best possible customer service. If you have any questions about your system, please call us at 1-855-235-5271 or visit
CellarCool.com.
Using the Manual
This Owners Manual is intended to assist in the proper installation maintenance of the system. In order to ensure the
longevity of your humidier, the equipment should be installed as outlined in the Owner’s Manual. It is also vital to
establish a proper care and maintenance schedule. Please read and review this manual carefully and keep it for future
reference.
www.cellarcool.com | Page 5
Receiving and Inspecting the System
• Lift only at the designated hand hold locations on the shipping container or fully support the unit from
underneath. A shipment may include one or more boxes containing accessories.
• Before opening the container, inspect the packaging for any obvious signs of damage or mishandling.
• Write any discrepancy or visual damage on the Bill of Lading before signing.
Note: CellarCool units are manufactured in the USA and tested prior to shipment.
Review the Packing Slip to Verify Contents
• Check the model number to ensure it is correct.
• Check that all factory options ordered are listed.
If any items listed on the packing slip do not match your order information,
contact CellarCool Customer Service immediately.
Check the Box for the following contents:
RECEIVING & INSPECTING THE SYSTEM
Please leave the unit in its original box until you are ready for installation. This will allow you to move the product
safely without damaging it. When you are ready to remove the product from the box, refer to the installation
instructions.
TIP: Save your box and all packaging materials. They provide the only safe means of transporting/shipping the unit.
(1) ACH 550 Humidier
(4) 2” #8 Hex Head Screws
(1) 10 FT. 1/2”Drain Line
(1) ACH 550 Owner’s Manual
(1) Humidistat w/25’of Cable
(1) 90° Barb Fitting
Main Humidier Box
ACH 033114
Page 6 | 1-855-235-5271
BEFORE YOU START
1. Inspect all components prior to installation. If damage is found, please contact your distributor or CellarCool
Customer Service at 1-855-235-5271.
2. It is REQUIRED to install a drain line to remove condensation from the Humidifier.
3. The system is intended for use in properly designed and constructed controlled rooms. Hire a professional
consultant with a valid contractor’s license to build your controlled room that is well insulated.
If you encounter a problem with your CellarCool unit, please refer to the Troubleshooting Guide on page 15. If you
have any further questions, concerns, or need assistance, please contact CellarCool’s Customer Service at 1-855-235-
5271. Please be sure all testing has been completed prior to contacting Customer Service. Please have your results
ready for your representative.
www.cellarcool.com | Page 7
Unobstructed Airow
Unobstructed airflow to and from the system is critical for the Humidifier’s overall performance and life-span. A
minimum three-foot clearance (five foot is ideal) area is crucial.
Note: Avoid attempting to camouflage the unit. This will restrict airflow and thus the systems’s ability to work
efficiently.
Mounting the Humidier
The Humidier must be mounted at least 3’from the oor in order to achieve sucient humidity. Mounting the
unit high in the room will contribute to a consistently humid environment.
Door and Door Seal
An exterior grade (1 3/4”) door must be installed as a cellar door. It is essential that weather stripping is attached to all
4 sides of the doorjamb. A bottom “sweep”or threshold is also required. The door must have a very good vapor seal
to prevent the moisture in the cellar from escaping. One of the most common problems with a humidifier running
continually is due to the door not sealing properly.
ACH 033114
Page 8 | 1-855-235-5271
ACTIVE HUMIDITY OPTION OVERVIEW
Use of the Active Humidity Option
Humidity may uctuate in the controlled room. The Active Humidity Option stabilizes the environment by adding
moisture when the relative humidity in the controlled room is becoming low. Using a humidistat and a water source,
the Active Humidity Option is able to regulate and establish a humid environment suitable for wine storage.
Note: The target humidity for most controlled rooms is between 50-70%.
General Active Humidity Option Recommendations
• Water source needs to have at least 40 psi.
• Water tubbing size: 1/4”O.D
• Water source should be tested for content and characteristics.
• In areas that are known to have hard water, the use of a Water-Softener System is required.
Note: Failure to install a Water-Softener or a Filtration system will allow an
excessive particle residue buildup and may lead to system failure.
• Even if the area is not known to have hard water, the use of a Filtration System (Particle Filter) is required.
• Use a Self-Piercing Saddle Valve as a simple connection to a water source.
• Clean or replace the Misting Nozzle every 12 months.
MISTING NOZZLE
Table des matières
