Carrier Integra 35X Manuel utilisateur

Truck Refrigeration

Operator’s Manual

for

35X with Standby

40X & 50X

Truck Refrigeration Units

with Cab Command Two Controller

62-11045 Rev C

Operator’s Manual

for

35X with Standby

40X & 50X

Truck Refrigeration Units

with Cab Command Two Controller

©Carrier Corporation, 2018 - Printed in U. S. A. April 2018

Table of Contents Page

Introduction.................................................................1

Safety.....................................................................2

Unit Identification .......................................................3

Unit Operation............................................................5

Keypad and Display...................................................6

Additional Key Functions...........................................7

Starting - Engine Operation......................................8

Starting - Standby Operation....................................9

Changing Display Brightness.................................10

Temperature Setpoint..............................................11

Manual Defrost...................................................... 12

Defrost Parameters............................................... 13

Defrost Interval.........................................................14

Minimum/Maximum Setpoint, Out-of-Range

and Continuous Airflow...........................................15

Stopping Unit............................................................16

Product Loading.......................................................17

Recommended Transport Temperatures................18

Problems and Alarms............................................ 19

Alarm and Error Display..........................................20

Alarm List ................................................................21

Alarm Reset .............................................................22

Standby Operation Guidelines................................23

Fuses - 40/50X........................................................24

Fuses – 35X (Road Only)......................................25

Fuses – 35X (230/3/60)..........................................26

Fuses – 35X (230/1/60)..........................................27

Fuses – 35X (115/1/60) ..........................................28

Unit Maintenance.................................................. 31

Emergency Road Service ..................................... 30

Introduction

This guide has been prepared for the operator of Carrier Transicold

35X with Standby, and 40X and 50X Truck Refrigeration units with

Cab Command, Two Controller. It contains basic instructions for

the daily operation of the refrigeration unit as well as safety

information, and other information that will help you to deliver the

load in the best possible condition. Pleasetake thetime toread the

information contained in this booklet and refer to it whenever you

have a question about the operation of your Carrier Transicold

unit.

Your refrigeration unit has been engineered to provide long, trouble-

free performance when it is properly operated and maintained. A

comprehensive maintenance program will help to insure that the unit

continues to operate reliably. Such a maintenance program will also

help to control operating costs, increase the unit’s working life and

improve performance.

This guide is intended as an introduction to your unit and to provide

general assistance when needed. More comprehensive information

can be found in the Operation and Service Manual for your unit. This

manual can be obtained from your Carrier Transicold dealer.

When having your unit serviced, be sure to specify genuine Carrier

Transicold replacement parts for the highest quality and best reli-

ability.

At Carrier Transicold, we are continually working to improve the

products that we build for our customers. As a result, specifications

may change without notice.





Safety

Your Carrier Transicold refrigeration unit has been designed with

the safety of the operator in mind. During normal operation, all

moving parts are fully enclosed to help prevent injury. During all

pre-trip inspections, daily inspections, and problem

troubleshooting, you may be exposed to moving parts; please stay

clear of all moving parts when the unit is in operation.

WARNING

Beware of unannounced starting of the fans caused by

the thermostat and the start/stop cycling of the unit.

Refrigerants

The refrigerant contained in the refrigeration system of your unit

can cause frostbite, severe burns, or blindness when in direct

contact with the skin or eyes. For this reason, and because of

legislation regarding the handling of refrigerants during system

service, we recommend that whenever your unit requires service

of the refrigeration system you contact your nearest Carrier

Transicold authorized repair facility for service.

WARNING

Inspect battery cables for signs of wear, abrasion or

damage at every pretrip inspection and replace if

necessary. Also check battery cable routing to ensure that

clamps are secure and that cables are not pinched or

chafing against any components.

Emergency Switch (40/50X units only)

The unit can be completely

shut down manually by the

emergency switch inside the

frame of the condenser unit.

The emergency switch must

be in the on position to allow

the unit to restart with the

“ON” key of the cab

command.

Emergency Switch





Unit Identification

The unit is identified by a nameplate attached to the frame of the

unit. This nameplate identifies the complete model number of the

unit, the serial number, the type of refrigerant and charge, and the

date the unit was placed in service.

If a problem occurs, please refer to the information on this plate,

and make a note of the model and serial number before calling for

assistance. This information will be needed when you contact a

technician or Carrier Transicold Service Engineer so that they may

properly assist you. 40/50X Nameplate

35X Nameplate





A : Evaporator

B : Condenser

C: Cab control

D : Compressor mounting kit

E : Vehicle battery

F : Standby plug

G : Main road fuse





Autres manuels pour Integra 35X

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels Carrier Réfrigérateur

Carrier

Carrier XARIOS X150-04 Manuel utilisateur

Carrier

Carrier TRANSICOLD 69NT20-274 Manuel d'utilisation

Carrier

Carrier Transicold Vector Manuel utilisateur

Carrier

Carrier Transicold X4 7300 Manuel utilisateur

Carrier

Carrier Container Refrigeration Unit Manuel utilisateur

Carrier

Carrier 69NT40-561-399 Manuel d'utilisation

Carrier

Carrier FV4B Manuel utilisateur

Carrier

Carrier 69NT40-541-304 Mode d’emploi

Carrier

Carrier BT30RF- EXPR Manuel utilisateur

Carrier

Carrier 40RM Manuel d'utilisation

Carrier

Carrier 17DA Manuel d'installation

Carrier

Carrier 40WAU Series Manuel utilisateur

Carrier

Carrier 69NT40-511-310 Instructions d'installation et d'utilisation

Carrier

Carrier Integra 20X Manuel utilisateur

Carrier

Carrier 19DA Manuel d'installation

Carrier

Carrier 69NT40-511-300 Manuel d'utilisation

Carrier

Carrier WeatherMaker 50A020-060 Manuel utilisateur

Carrier

Carrier VECTOR 6500 Instructions d'installation et d'utilisation

Carrier

Carrier 69NT40-551-001 Manuel d'utilisation

Carrier

Carrier 69NT40-511-1 Manuel d'utilisation

Carrier

Carrier Streamline Scroll 69NT20-531-300 Manuel d'utilisation

Carrier

Carrier SUPRA 850Mt Manuel d'utilisation

Carrier

Carrier NEOS 100S Instructions d'installation et d'utilisation

Carrier

Carrier 69NT40-551-500 Manuel d'utilisation

Manuels Réfrigérateur populaires d'autres marques

Bonnet Neve

Bonnet Neve SKYVIEW PLUS Manuel utilisateur

Zanussi Electrolux

Zanussi Electrolux ZERB 8441 Manuel utilisateur

Sharp

Sharp SJ-BA31IEXW2-EU Manuel utilisateur

CORBERO

CORBERO CC2300MCW Manuel utilisateur

KitchenAid

KitchenAid 2205264 Manuel utilisateur

Stengel

Stengel KU 1101 A++ Manuel utilisateur

NEFF

NEFF KI181 Series Manuel utilisateur

Hoshizaki

Hoshizaki Reach-In Manuel utilisateur

Amana

Amana ASD2524VES00 Manuel utilisateur

BOMANN

BOMANN KGC 213 Manuel utilisateur

Danby

Danby DAR044A1SLDD Instructions de montage

Samsung

Samsung RF323TE Manuel utilisateur

Beko

Beko CSA31022 Manuel utilisateur

IKEA

IKEA FROSTIG C 185 E Manuel utilisateur

Electrolux

Electrolux ER 6821 D Manuel utilisateur

True

True TS-28 Manuel utilisateur

Frigidaire

Frigidaire FSC23R5DW9 Manuel utilisateur

Beko

Beko LSP4579W Manuel utilisateur