Canon IR5570 Series Manuel de référence

(1/5)

Service Bulletin

Issued by Canon Europa N.V. Copier B/W

Hardware

Location:

Scanner Mount Assembly

Subject:

Measures against white lines in sub scanning direction due to deformation of Primary Fan Duct

Detail:

White lines occur in the sub scanning direction.

<Cause>

A Primary Fan Duct [FL2-3018] is partially warped to the Primary Corona Assembly (to the left) [1]. Then, a Cleaner

Pad stops during its operation to cause white lines in the sub scanning direction.

Add a tap hole to the position a scanner stays in the copier and fix the Primary Fan Duct (FL2-3018) with a screw so

as to prevent it from warping.

Model:

iR5570

iR6570

Ref No.:

iR6570-013

(F1-T01-0M5-10039-01)

Date:

January, 2006

P-1 AP kit is dismounted

[1] Warped position of Primary Fan Duct

iR6570-013

(2/5)

Service work:

When the symptom above occurs, carry out the following procedure.

1. Refer to "Service manual" > "Image formation" > "7.10.3 Primary Charging Assembly", remove the Primary

Corona Assembly from the copier and check if the part [2] of Primary Fan Duct is warped to the Corona Assembly

(to the left).

2. If it is warped like [2], refer to "Service manual" > "Image formation" > "7.10.1 Process Unit" and remove the

Process Unit (AP kit) from the copier.

3. Unscrew two screws [3] and remove the Primary Fan Duct [4].

iR6570-013

(3/5)

4. Prepare the Primary Fan Duct, affix two-sided tape to the Duct as shown in [5] and then remove the release paper

from the tape.

Note: Affix two-sided tape to the position as shown in [6], not lying off the edge of the mold and within 0.5mm from

the edge (OK for extending onto the molt plane).

5. Mount the Primary Fan Duct on the copier with two screws. First, set the Duct [7], hitch two rear Claws of the

Duct to two positions [8] and pull the Duct frontward.

[6] Unacceptable of lying off edge of mold / Within 0.5mm from edge

iR6570-013

(4/5)

6. Affix the side of the Duct with the two-sided tape (at step 4) to the upper Sheet Metal. Be sure that the Sheet Metal

is straight as shown in [10] not warped as shown in [9].

7. Mount the AP-kit on the copier and make sure that the Primary Fan Duct does not extend off the Primary Corona

Rail of the AP-kit as shown in [11]. If it extends off, mount the Primary Fan Duct again.

8. Mount the Primary Corona Assembly, carry out "Additional Function" > "Adjustment/Cleaning" > "Wire

Cleaning" and ensure that the Cleaner Pad can work normally.

Service part:

Part number Description Q'ty I.C. PC Page

Old

215

New FY1-1245-000 TAPE, PRIMARY FAN

DUCT 0->1 -

iR6570-013

(5/5)

Affected machines:

iR6570 120V KHN00372 and later

iR5570 120V KHT01604 and later

iR6570 230V KHP00011 and later

iR5570 230V KHU00014 and later

Autres manuels pour iR5570 Series

Ce manuel convient aux modèles suivants

Table des matières

Autres manuels Canon Photocopieuse

Canon

Canon CLC 1100 Manuel utilisateur

Canon

Canon imageRUNNER ADVANCE DX C3835i Guide d'installation

Canon

Canon imageRUNNERC1022 Manuel utilisateur

Canon

Canon imageRunner Advance 6275 Instructions de montage

Canon

Canon NP6551 Manuel utilisateur

Canon

Canon IMAGERUNNER 2020 Manuel utilisateur

Canon

Canon iR ADV C55 i Series Guide de l'administrateur

Canon

Canon imageRUNNER 5055 Manuel utilisateur

Canon

Canon imageRUNNER 1750i Manuel utilisateur

Canon

Canon imageRunner iR2270 Manuel utilisateur

Canon

Canon imageRUNNER 3300 Manuel d'instructions et de sécurité

Canon

Canon iR C3200 Series Manuel utilisateur

Canon

Canon NP7161 Manuel utilisateur

Canon

Canon DADF-M1 Manuel de référence

Canon

Canon iR1210 Manuel utilisateur

Canon

Canon Z5000 Manuel utilisateur

Canon

Canon iR1210 Manuel de référence

Canon

Canon GP605 Manuel utilisateur

Canon

Canon CLC 1130 Manuel utilisateur

Canon

Canon NP-1215 Manuel utilisateur

Canon

Canon NP6330 Manuel utilisateur

Canon

Canon PC140 Manuel utilisateur

Canon

Canon imageRUNNER C3480 Manuel utilisateur

Canon

Canon iR5570 Series Manuel de référence

Manuels Photocopieuse populaires d'autres marques

Ricoh

Ricoh FW740 Manuel utilisateur

Minolta

Minolta CF910 Manuel utilisateur

Ricoh

Ricoh B003 Manuel utilisateur

Xerox

Xerox EC70 Manuel utilisateur

Oce

Oce 9800 Manuel utilisateur

Olivetti

Olivetti d-Copia 1800 Manuel utilisateur

Minolta

Minolta Di181 Manuel utilisateur

Telecrane

Telecrane F25 Manuel utilisateur

Xerox

Xerox WorkCentre Pro 40 Manuel utilisateur

Sharp

Sharp AR-5015 N Manuel utilisateur

Ricoh

Ricoh Di-C1 Manuel utilisateur

Mita

Mita MIP-2400 Manuel

Sharp

Sharp AL-2061 Manuel utilisateur

Muratec

Muratec MFX-C2280 Manuel utilisateur

Ricoh

Ricoh FT5034C Manuel utilisateur

Minolta

Minolta EP4000 Manuel utilisateur

Ricoh

Ricoh V-C3 Guide d'installation

Triumph Adler

Triumph Adler DCC 2526 Manuel