BBQ BQ04025 Manuel utilisateur

Grill Guide

For Model BQ04025

LP Gas Barbecue Grill

FOR YOUR SAFETY:

1. Read this Grill Guide before attempting to assemble or operate your grill.

2. Follow all safety instructions.

3. Check for leaks according to directions in this Grill Guide before operating your grill,

even if a retailer assembled this grill.

4. Keep this Grill Guide for future reference.

5. Contact 1-800-933-0527 should you need assembly assistance or have any questions.

TO THE INSTALLER OR PERSON ASSEMBLYING THIS GRILL:

Leave this Grill Guide with the grill for future reference.

THIS GRILL IS FOR OUTDOOR USE ONLY.

If stored indoors, then detach and leave propane cylinder outside.

POUR UTILIZATION A L’EXTERIEUR SEULEMENT.

Si Appareil est entrepose a l’intérieur; enlever les bouteilles et les laisser a Pexterieur.

Safety Precautions

Always read and follow all DANGER, WARNING, AND FOR YOUR SAFETY notices in this Grill

Guide. Failure to do may result in serious bodily injury or death, or in a fire or an explosion causing

damage to property.

1. Grill installation must conform with local codes, or in their absence, with either the National Fuel

Gas Code, ANSI Z223.1, or CAN/CGA-B149.1 Natural Gas Installation Code or CAN/CGA-

B149.2, Propane Installation Code.

2. Handling and storage of LP cylinders must conform to LP Gas Code NFPA/ANSI 58 or

CAN/CGA-B149.2.

3. This gas grill is not intended to be installed in or on recreational vehicles and/or boats.

4. This grill is safety certified for use in the United States and Canada only. Do not modify for use in

any other location. Modification will result in a safety hazard.

5. Never use any other type of fuel for this grill other than LP gas.

6. Only use the pressure regulator with a type 1 connector that is supplied with this gas grill.

7. Check all gas hoses for fraying, cracking, or excessive wear. Replace any with those signs before

using the grill.

8. Always perform a Leak Test before operating your grill.

! FOR YOUR SAFETY !

1. Do not store or use gasoline or other

flammable vapors and liquids in the

vicinity of this or any other appliance.

2. An LP cylinder not connected for use shall

not be stored in the vicinity of this or any

other appliance.

! FOR YOUR SAFETY !

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open lid.

4. If odor continues, immediately call your

gas supplier or your fire department.

! AVERTISSEMENT !

1. Ne pas entreposer Ni utiliser de l’essence

ni d’autres vapeurs on liquids

inflammables dans le voisinage de

l’appareil, ni de tout autre appareil.

2. Une bouteille de propane qui n’est pas

recordée en vue de son utilisation, ne doit

pas être entreposée dans le voisinage de cet

areil ou de tout antre a

areil.

! AVERTISSEMENT !

S’il y a une odeur de gaz:

1. Coupez l’admission de gaz de l’appareil.

2. Éteindre toute flamme nue.

3. Ouvrir le couvercle.

4. Si l’odeur persiste, appeler immédiatement

votre compagnie de gaz ou votre

department des incendies.

! WARNING !

Combustion by-products produced when using this product contain chemicals known to the State o

California to cause cancer, birth defects, and other reproductive harm.

Table of Contents

Safety Precautions……….……………………………..……………...…………...…… 2

Table of Contents…………………….…………………………………..……….……...3

Warranty……………………………….………………………………………….…….. 4

Customer Support Center……………….………………………………………….…….4

Assembly Instructions...…………………………………………………………..…..5-15

General Information and Operation………………..………………………………..16-24

Trouble Shooting Guide……………………………………………….................….25-26

Owner Registration Card……………….……………………………………...........27-28

Write down here and keep for future

reference

Date of Purchase: _________________

Serial Number: ___________________

The serial number may be found on the placard located on the back of

the grill

Kmart Corporation

3100 West Big Beaver Road

Troy MI 48084-3163

1-248-463-1000

Visit us at: www.kmart.com

Limited Warranty

The manufacturer warrants to the original

consumer-purchaser that this product shall be

free from defects in workmanship and materials

under normal and reasonable use when

assembled and operated according to this Grill

Guide from date of purchase as follows:

Stainless Steel and Die Cast Parts - 99 years

Stainless Steel Burners - 10 years

Remaining Parts – 2 years

The manufacturer will, at its option, refinish or

replace any product or part found to be defective

during the limited warranty period. The

manufacturer may require you to return the

part(s) claimed to be defective for its inspection,

freight or postage prepaid. Contact our Customer

Support Center as shown below before returning

any part(s).

Additional information can be obtained by

writing: Barbecue Grills

Warranty Dept.

1375 Mitchell Blvd

Schaumburg, IL 60193

The manufacturer will require reasonable proof

of purchase. We strongly recommend you keep

your sales receipt and register your grill. You

can attach your receipt to this guide.

This limited warranty does not cover the cost of

any inconvenience or property damage due to

failure of the product and does not cover damage

due to misuse, abuse, alteration, improper or

failure to perform normal and routine

maintenance, discoloration, accident, or damage

arising out of transportation of the product. This

limited warranty will not apply to any grill used

for commercial use.

This limited warranty is the sole warranty given

by the manufacturer and is in lieu of all other

warranties; express or implied, including implied

warranty of merchantability or fitness for a

particular purpose. Neither manufacturer dealers

nor the retail establishment selling this product

have any authority to make any warranties or to

promise remedies in addition to or inconsistent

with those stated above.

This limited warranty applies only to products

sold at retail, and is not transferable.

The manufacturer's maximum liability, in any

event, shall not exceed the purchase price of the

product paid by the original consumer-purchaser.

Some states do not allow the exclusion or

limitation of incidental or consequential

damages. Therefore, the above limitations or

exclusions may not apply to you. This warranty

gives you specific legal rights and may also have

other rights, which vary from state to state.

Customer Support Center

Thanks for purchasing a BBQ Pro™ Grill. We’re here to help you maximize your enjoyment and appreciation

of your new grill. Please don’t hesitate to contact us should you have any questions regarding assembly,

performance, warranty, or accessories. Please have your model number ready before you contact us. We’re here

to serve You!

• If you need assistance or to order parts: Call 1-800-933-0527 or send a FAX to 1-847-252-1001.

• Business hours: Monday through Friday; 8:30AM-5:00PM Central Time.

• Visit us on the web at: www.omahagrills.com

Assembly Instructions

This page will give you an overview of information to assemble your grill. The following pages will show in

step-by-step detail how to do so. We offer the following suggestions to make your grill assembly as easy as

possible.

1.) Read through the entire Assembly Instructions before you begin.

2.) Choose an area large enough to comfortably lay out all the parts and hardware with enough room to easily

maneuver.

3.) Have an area with a non-abrasive surface where you can lay parts without scratching them.

4.) Use 2 people to remove the Cabinet and Firebox Assembly from the carton. You will also need 2 people to

attach the Casters to the Cabinet and Firebox Assembly.

5.) Lay all parts and hardware out and ensure you have everything listed on the Parts and Hardware page before

you begin assembly. See the Customer Support Page for contact information should any parts be damaged or

missing.

6.) A Phillips Head Screwdriver has been provided for assembly. You will not need any additional tools.

7.) Do not use a Power Screwdriver for assembly as you could strip the threads on the Nuts and Bolts.

8.) The propane tank for this grill is sold separately. See the LP Gas and Cylinder Information later in this

guide. BQ04025

! WARNING !

Failure to follow all Danger,

Warnings, and For Your Safety

notices in this Grill Guide may

result in serious bodily injury o

death, or in a fire or an explosio

causing damage to property.

! CAUTION !

Perform the Leak Test explaine

later in this Grill Guide before

operating your grill.

BQ04025 Detail Parts List

1.Thermometer 31.Pan Support

2.Thermometer Seat 32.Side Burner Shelf Frame

3.Stainless Steel Lid - Outer 33.Side Burner Cover Support

4.Logo Plate 34.Side Burner Inside Frame

5.Name Plate 35.Side Burner Electrode

5.Lid Side Panel - Right 36.Grease Pan Handle

6.Lid Side Panel - Left 37.Grease Pan

7.Hood Handle 38.Side Burner

8.Silicon Stopper 39.Side Burner Front Panel

9.Stainless Steel Lid - Inner 40.Side Burner Front Bracket

10.Firebox - Back 41.Side Burner Rear Bracket

11.Heat Shield for Firebox - Inner 42.Side Burner Valve

12.Electrode 43.Cylinder Support Ring

13.Firebox - Right Side 44.Manual Igniter

14.Firebox - Left Side 45.Cabinet - Right Side Panel

15.Firebox - Front 46.Cabinet - Bottom Shelf

16.Bottom Heat Shield 47.Right Side Table

17.Main Burner Bracket 48.Right Side Table Front Panel

18.Gas Manifold Assembly 49.Right Side Table Rear Bracket

19.Gas Hose 50.Right Side Table Front Bracket

20.Regulator and Hose 51."S" Hooks

21.Heat Diffuser 52.Cabinet Crossbar

22.Burner 53.Cabinet - Left Side Panel

23.Control Knob 54.Caster Cap

24.Control Knob Seat 55.Standard Caster

25.Electric Igniter 56.Locking Caster

26.Heat Shield for Control Panel - Inner 57.Cabinet - Front Panel

27.Heat Shield for Control Panel - Outer 58.Condiment Basket

28.Control Panel 59.Cooking Grate

29.Warming Rack 60.Cotter Pin

30.Side Burner Cover

! WARNING !

DO NOT DISPOSE OF BATTERIES IN FIRE.

BATTERIES MAY EXPLODE OR LEAK.

Table des matières

Manuels Barbecue à gaz propane populaires d'autres marques

Members Mark

Members Mark BQ06042-1 Manuel utilisateur