ALS DTS-UESIGHT Manuel

Airfield Lighting Systems UK Limited

Aviation House, Russel Gardens, Wickford, Essex, SS11 8BF

Tel +44 1702 547562 Fax +44 1702 533962 Web www.alsukltd.co.uk Email sale[email protected].uk

DTS Uni-Directional Elevated Lights

Sighting Device

Part Code DTS-UESIGHT

Operation & Maintenance Manual

Document Number: MAN010 – REV C

Contents

Airfield Lighting Systems UK Limited

Aviation House, Russel Gardens, Wickford, Essex, SS11 8BF

Tel +44 1702 547562 Fax +44 1702 533962 Web www.alsukltd.co.uk Email sale[email protected].uk

1.0 History of Change

2.0 Warranty / Calibration

3.0 Contents

4.0 Installation

5.0 Spares Listing

1.0 History of Change

Page Revision

Description

Checked

Approved

Date

All A Manual Released AK DJ 06/04/2021

All B Updated TLS AK 18/10/2021

All C Uni-directional changes DJ AK 21/10/21

2.0 WARRANTY

Airfield Lighting Systems UK LTD, (ALS), guarantee their sighting devices for a period of two

years against faulty components.

ALS products are constructed using high performance materials. The use of replacement parts or

other materials not obtained from or approved by the company, may lead to impaired performance

or reduced service life. The warranty given by Airfield Lighting Systems will be invalidated if non-

approved replacement parts are used.

The device should be returned to ALS for alignment calibration every 2 years or sooner if any

damage has occurred or the unit has been dropped.

The satisfactory operation of the device depends upon the observance of the recommended setup

and storage instructions given in this manual. Failure to do so will invalidate this warranty.

Airfield Lighting Systems UK Limited

Aviation House, Russel Gardens, Wickford, Essex, SS11 8BF

Tel +44 1702 547562 Fax +44 1702 533962 Web www.alsukltd.co.uk Email sale[email protected].uk

3.0 CONTENTS

Please carefully read and observe all safety related warnings throughout this manual. Failure to

do so could result in damage to the device / light fitting and serious injury if the Airfield light is

incorrectly installed.

Please observe all local site and regional safety requirements before commencing work on any

Airfield. Installation and operation of the sighting device must only be carried out by qualified and

competent persons.

The Sighting Device consists of a circular mounting bracket and positioning studs, hand-tightening

screws, a telescopic sight (marked with angles for field vision), a gauge to see the angle of

adjustment and spirit level bubble to confirm the correct angle is set.

(Fig 1)

Telescopic sighting device

and spirit level bubble

Tightening screws to firmly

secure bracket

Mounting bracket to attach

to front of light fitting

Airfield Lighting Systems UK Limited

Aviation House, Russel Gardens, Wickford, Essex, SS11 8BF

Tel +44 1702 547562 Fax +44 1702 533962 Web www.alsukltd.co.uk Email sale[email protected].uk

4.0 INSTALLATION

First remove all the items from the box and check all the components are present as shown in

Figure 1.

The light fitting is set at 2.50 in the factory, but this should be checked on site. There is no

need to adjust the fixing screws on the neck of the fitting pole until after using the sighting

device is fitted. (Fig 2)

a) Commence mounting the bracket to the light fitting (Fig 3)

(Fig 2) DTS fitting (Fig 3) align the brackets concaved area to this screw

b) The sighting device first attaches to the front of the light fitting, place the top of the bracket

over the screw for correct placement (Fig 3) then position the bracket flat to the front of the

fitting. Hold the bracket securely so it does not fall off until both tightening screws are fully

tightened on both sides.

Airfield Lighting Systems UK Limited

Aviation House, Russel Gardens, Wickford, Essex, SS11 8BF

Tel +44 1702 547562 Fax +44 1702 533962 Web www.alsukltd.co.uk Email sale[email protected].uk

c) Once the bracket is correctly placed over the front rim of the light fitting, twist the screws

clockwise over the front rim to secure the sighting device on to the light fitting.

4.1 SETTING THE SIGHTING DEVICE

a) The DTS light fitting is Uni-directional and must be set up precisely. After its installation on the

Airfield, please adjust the angle of azimuth and sight to complete installation prior to any

operation by Aircraft.

b) When the sighting device is fully secured on the light it is ready to be adjusted.

c) The sighting device can be used in four directions (Front/Rear/Left/Right) for alignment with

other fittings on the Runway or sighting reference. The telescopic sight rotates 90 degrees at

a time on the top of the DTS fitting to allow setting.

d) Good practice is to take another fitting in the same direction of the light and use this as a target

to aim the sighting device at.

e) Check to determine the angle required to local regulations i.e. ICAO, EASA, CAP168 etc

f) The sighting device can be adjusted to a positive or negative toe-in of 1.50, 20,30, 3.50,40,4.50

or 50 by looking into the telescope

(Fig 4)

Airfield Lighting Systems UK Limited

Aviation House, Russel Gardens, Wickford, Essex, SS11 8BF

Tel +44 1702 547562 Fax +44 1702 533962 Web www.alsukltd.co.uk Email sale[email protected].uk

g) To adjust the angle required, slide the spirit level assembly forwards or backwards to align the

marker at the top with the required angle visible through the window on the sighting device.

h) Check the spirit level bubble on the top of the sighting device, if it is level then no adjustment

is required and the fitting is ready to be used.

i) To change the angle, adjust the locking screws on the base of the unit until the spirit level

bubble is in position and then re-tighten them. Adjust each screw separately and in turn i.e. do

not tighten one fully first then the next one, adjust them all equally so as to not move the final

setting.

Airfield Lighting Systems UK Limited

Aviation House, Russel Gardens, Wickford, Essex, SS11 8BF

Tel +44 1702 547562 Fax +44 1702 533962 Web www.alsukltd.co.uk Email sale[email protected].uk

4.2 STORAGE OF THE DEVICE

a) Once the sight has been removed please return to the protective bag and box for security to

store the device before use again.

b) The sighting device should be stored indoors at room temperature.

5.0 SPARES

All individual items shown in Fig 1 are available as serviceable parts and can be ordered from

ALS.

This includes the screws and mounting bracket. The telescope and mount are one complete

piece.

Table des matières

Autres manuels ALS Équipement d'éclairage

ALS

ALS ELEDN Tunable White Manuel utilisateur

ALS

ALS ELEDN4 Manuel utilisateur

ALS

ALS PEP-11WW2 Manuel utilisateur

ALS

ALS SLM1K2R Manuel utilisateur

ALS

ALS AUD502H Manuel utilisateur

ALS

ALS RB/IN-WW(L)-C Manuel utilisateur

ALS

ALS FLEXY 300 CRI90 Manuel utilisateur

ALS

ALS AUD202H Manuel utilisateur

ALS

ALS PEN153R Manuel utilisateur

ALS

ALS PEN154R Manuel utilisateur

ALS

ALS HBA-60NW2 Manuel utilisateur

ALS

ALS ELEDQ Manuel utilisateur

ALS

ALS ELEDN Manuel utilisateur

ALS

ALS FLEXY2-600SW Manuel utilisateur

ALS

ALS DEL-13SW3 Manuel utilisateur

Manuels Équipement d'éclairage populaires d'autres marques

Brizo

Brizo 8SP-MU-4 Manuel utilisateur

LUCE&LIGHT

LUCE&LIGHT BROM 1.0 Manuel utilisateur

IKEA

IKEA BJÖRKSPIREA Manuel utilisateur

Laserworld

Laserworld Evolution Series ES-400RGB Manuel utilisateur

Alien

Alien RG STAR Manuel utilisateur

EuroLite

EuroLite LED B-40 Manuel utilisateur

Qazqa

Qazqa Suplux SL 3 Black 103062 Manuel utilisateur

Commercial Electric

Commercial Electric 54568141 Manuel utilisateur

CREE LIGHTING

CREE LIGHTING 304 Series Manuel utilisateur

Goobay

Goobay 49867 Manuel utilisateur

ECOMAN ITALIA

ECOMAN ITALIA LED T8 Manuel utilisateur

Alkalite

Alkalite Krypton KT-81 Manuel utilisateur

Clas Ohlson

Clas Ohlson GU10 Manuel utilisateur

DTS

DTS DELTA 10 F Manuel utilisateur

ring

ring Solar Steplight Manuel utilisateur

One Stop Gardens

One Stop Gardens 57696 Instructions de montage

Chauvet DJ

Chauvet DJ COREpar UV120 ILS Manuel utilisateur

SIREM

SIREM Swimeo A2 Manuel utilisateur